Abstract:Localized corrosion such as pitting and mesa attack caused by the presence of solid deposits on a metal surface is defined as under deposit corrosion (UDC). UDC is frequently observed in oil and gas transition pipelines where sand, debris biofilm and carbonate deposit are present. Studies have found that the introduction of oxygen would accelerate the galvanic corrosion behavior between the deposit covered area and the area without deposit. Some experiments have been carried out and demonstrated that high concentration inhibitor should be used for the migration of UDC. However, the inhibition effect of the organic phosphonic inhibitor for UDC is rare in the previous studies. In this work, the evaluation of UDC behavior of X65 pipeline steel and the performance of corrosion inhibitor Ethylene Diamine Tetra (Methylene Phosphonic Acid) Sodium (EDTMPS) in the oxygen contained solutions are studied by using polarization dynamic scan (PDS), electrochemical impedance spectra (EIS) and linear polarization resistance (LPR) methods. The galvanic effect caused by the deposit is studied by using wire beam electrode (WBE). The measurement results show that the corrosion rate of deposit-covered electrode is lower than that of bare electrode, but localized corrosion is observed on the deposit-covered steel surface. After 35 mg/L EDT-MPS is introduced into the solution, the corrosion rate of the bare steel decreased from 0.17 mm/a to 0.082 mm/a and the corrosion rate of the deposit covered electrode decreased from 0.051 mm/a to 0.026 mm/a. Protective films are observed on both deposit covered steel surface and bare steel surface after EDTMPS added. In the galvanic corrosion monitoring experiment by using WBE, the under deposit area has a lower potential and performs as the anodic area with serious localized corrosion. After 35 mg/L EDTMPS is injected, the average potential begins to decrease. The maximum anodic current density and the total anodic current respectively decrease from 0.21 mA/cm(2) and 0.056 mA to 0.078 mA/cm(2) and 0.021 mA. The electrochemical measurement results reveal that EDTMPS has an excellent inhibition effect for the corrosion of both bare electrode and deposit covered electrode. The WBE test illustrates that EDTMPS also has an inhibition effect on the galvanic corrosion caused by the covering deposit. However, EDTMPS cannot completely prevent the localized corrosion behavior on WBE surface.

Experimental Evaluation of Anticorrosion of a Standard 20# Gathering Pipeline by Injecting Oxygen-Reduced Air into Simulated In-Service Wells

Research on Evaluation of Corrosion Inhibitors for Oxygen Reducing Air Drive Gas Wells

Corrosion Inhibition Properties of Corrosion Inhibitors to under-Deposit Corrosion of X65 Steel in CO2 Corrosion Conditions

Study on the foam releasion corrosion inhibitor for natural gas gathering and transferring metal pipe

Study on the Corrosion Mechanism of N80 Steel in Simulated Oxygen-Reduced Air Drive Production Wellbores

Applicable Scope of Oxygen-Reduced Air Flooding and the Limit of Oxygen Content

Effect of O2 on down-hole corrosion during air-assisted steam injection for heavy oil recovery

Study on corrosion inhibitor technology in gas pipeline

Application and Research of CO2 Corrosion Inhibitors in Oil-gas Field

Corrosion Inhibitor Distribution and Injection Cycle Prediction in a High Water-Cut Oil Well: A Numerical Simulation Study

Study on CO2 Corrosion Behavior of Underground Gas Storage Pipe Columns and Establishment of Corrosion Inhibition System

Corrosion Control in CO2 Enhanced Oil Recovery from a Perspective of Multiphase Fluids

Research progress on factors affecting oxygen corrosion and countermeasures in oilfield development

Experimental Investigation on Corrosion Behavior of X80 Pipeline Steel under Carbon Dioxide Aqueous Conditions

CO2-O2-SRB-Cl− Multifactor Synergistic Corrosion in Shale Gas Pipelines at a Low Liquid Flow Rate

Study and Application of the Corrosion Inhibitor for Completion Fluid in a Gas Field of Changqing Oilfield

Investigation into main controlling factors and prediction model of L245NS steel corrosion rate in CO2–O2–SO2–H2S–H2O environment

Corrosion Behavior of Pipeline Steel under Deposit Corrosion and the Inhibition Performance of Organic Phosphine Inhibitor

Experimental and Simulation Study of Atomization Concentration of Corrosion Inhibitor in a Gas Pipe

Localised corrosion failure of an L245N pipeline in a CO2–O2–Cl− environment

Corrosion Inhibition of Carbon Steel in Co2-Containing Oilfield Produced Water in the Presence of Iron-Oxidizing Bacteria and Inhibitors