Abstract:This paper introduces the new fast response aerodynamic probe (FRAP®), which was recently developed at the ETH Zurich. The probe provides time-resolved, three-dimensional flow measurements using the virtual four sensor technique. Two probes work in tandem, being comparable to a pair of pneumatic needle probes. The first probe, being yaw angle sensitive, is positioned in three circumferential positions. The second probe being pitch angle sensitive is brought into exactly the same position as the first probe. The resulting set of four measurements is phaselock-averaged to one specific rotor trigger position. Then the reduced data sets are combined to four calibration coefficients, which are then further processed to determine the unsteady flow vector. The results consist of yaw and pitch flow angles as well as the total and static pressure. The outer diameter of the cylindrical probe head was miniaturized to 0.84mm, hence probe blockage effects as well as dynamic lift effects are reduced. The shape of the probe head was optimized in view of the manufacturing process as well as aerodynamic considerations. The optimum geometry for pitch sensitivity was found to be a cylindrical surface with the axis perpendicular to the probe shaft. The internal design of the probes led to a sensor cavity eigen frequency of 44 kHz for the yaw sensitive and 34kHz for the pitch sensitive probe. The steady aerodynamic characteristics of the probe were measured using the free jet probe calibration facility of the laboratory. The full set of calibration surfaces is given. Data acquisition is done with a fully automated traversing system, which moves the probe within the test rig and samples the signal with a PC-based A/D-board. An error analysis implemented into the data reduction routines revealed acceptable accuracy for flow angles as well as pressures for many turbomachinery flows. Depending on the dynamic head of the application the yaw angle is accurate within ±0.35° and pitch angle within ±0.7°. Finally, a comparison of time averaged results to five hole probe measurements is discussed.

Derivation of Multi-Grid Discrete and Analytic Green's Functions Free of Poles in Terms of Transverse Waves

Measurements of the Airflow Velocity Using Ultrasonic Transducers

Monofiber optical probe using Doppler signals detection for Drop Size and Velocity measurement in air assisted atomization

High-speed camera-based measurement system for aeroacoustic investigations

An accurate ultrasonic wind speed and direction measuring method by combining time-difference and phase-difference measurement using coded pulses combination

Road to Acquisition: Preparing a MEMS Microphone Array for Measurement of Fuselage Surface Pressure Fluctuations

Calibration of 3-D wind measurements on a single-engine research aircraft

Development of an Accurate and Robust Air-Coupled Ultrasonic Time-of-Flight Measurement Technique

An innovative ultrasonic time of flight method based on extended Kalman filter for wind speed measurement

Topical application of doxepin hydrochloride can reduce the symptoms of complex regional pain syndrome: a case report.

Implementation of a Novel Pulsed Ultrasonic Doppler Velocity Profiler

Virtual four sensor fast response aerodynamic probe (FRAP®)

Development of a wireless, non-intrusive, MEMS-based pressure and acoustic measurement system for large-scale operating wind turbine blades

AeroMEMS Sensor with Integrated Pressure and Hot-Wire Sensor for High-Frequency Transition Detection

ANEMOMETER WITH THREE-DIMENSIONAL DIRECTIONALITY FOR DETECTION OF VERY LOW SPEED AIR FLOW AND ACOUSTIC PARTICLE VELOCITY DETECTING CAPABILITY

Flow Structure around a Multicopter Drone: A Computational Fluid Dynamics Analysis for Sensor Placement Considerations

Combined free-stream disturbance measurements and receptivity studies in hypersonic wind tunnels by means of a slender wedge probe and direct numerical simulation

Water-Cooled Fast-Response Wall-Static Pressure Probes for Harsh Combustor Environment Applications

Aerodynamic Measurements of Hypersonic Free-Flight via Optical Tracking and Bayesian State Estimation

Aeronautics Application of Direct-Detection Doppler Wind Lidar: An Adapted Design Based on a Fringe-Imaging Michelson Interferometer as Spectral Analyzer

Estimation of Airspeed, Angle of Attack, and Sideslip for Small Unmanned Aerial Vehicles (UAVs) Using a Micro-Pitot Tube