Abstract:The main technical challenge of the medium-voltage Permanent Magnet Synchronous Motor (PMSM) drives with Modular Multilevel Converter (MMC) is the serious low-frequency fluctuation on the capacitor voltages. Therefore, a Hybrid Low Capacitance MMC (HLC-MMC) topology based on horizontal sub-module (SM) interconnection is proposed in this paper. Based on the three-phase symmetry of the input fluctuation currents of the sub-modules of the HLC-MMC, a fluctuation current coupling channel is established between the sub-modules with the same horizontal position of the three phases. The fluctuation currents are coupled and cancelled in the interconnection channel, and the amplitude of the fluctuation currents flowing into the sub-module capacitors is reduced. A switch tube in series with the DC bus is turned on and off at a regular frequency. The average DC voltage component in the bridge arm voltage is reduced and the voltage ripple of the capacitor is reduced. Then, a new control method is proposed for the HLC-MMC topology, where the energy is equalized between the upper and lower bridge arms of each stage by adjusting the fundamental frequency current components. The switching frequency of the series switches on the DC bus is controlled by duty cycle, and the measured average voltage of the control sub-module capacitors is equal to the reference voltage value. The overall energy of the system is balanced and the sub-module capacitor voltage ripple is further reduced. The correctness and effectiveness of the topology and the proposed control method are verified by simulation.

Boost-Based Active Power Decoupling Converter With Voltage Complementary for Electrolytic Capacitor-Less PMSM Drive System

Current Control Scheme for LC-Equipped PMSM Drive Considering Decoupling and Resonance Suppression in Synchronous Complex-Vector Frame

Robust Control of Winding-Based DC-Bus Capacitor Discharge for PMSM Drives in Electric Vehicles

DC-Bus Capacitor Maximum Power Discharge Strategy for EV-PMSM Drive System with Small Safe Current

Admittance Reshaping Based on Adaptive Minimum Value of DC-Link Voltage for IPMSM Drive with Small Film Capacitor

Structural Design of A Five-Level Hybrid Active Npc Converter for High Power Density Motor Drives

Active Power Decoupling for a Modified Modular Multilevel Converter to Decrease Submodule Capacitor Voltage Ripples and Power Losses

A Multiplexing Modulation Strategy Based On Single-Phase Ac/Dc Converter With Optimized E-Capless Function

Dynamic DC-Link Over-Voltage Mitigation Method in Electrolytic Capacitor-Less Adjustable Speed Drive Systems

Adaptive Stability Control Strategy for Electrolytic Capacitor-less Permanent Magnet Motor Drives

Power Decoupling Control for Single-Stage On-Board Chargers

Review of electrolytic capacitor-less PMSM drives

Research on Flux-Weakening and DC-link Voltage Compensation of PMSM Drive System Without Electrolytic Capacitor

Stability Improvement of V/f Control Scheme with Active Damping for Small Capacitor IPMSM Drive System

An Improved Power-Decoupling Scheme with Grid Inductor Phase-Shift Modification for Single-Phase Converter

Control and Modulation of a Single-Phase AC/DC Converter with Smooth Bidirectional Mode Switching and Symmetrical Decoupling Voltage Compensation

A Hybrid Low Capacitance Modular Multilevel Converter for Medium Voltage PMSM Drive and Its Control Method

Resonance Analysis And Suppression Strategy For Electrolytic Capacitor-Less Permanent Magnet Synchronous Motor Drives

Beatless Control Strategy Based on Impedance Reshaping for PMSM Drives with Small DC-Link Capacitors

Active Power Decoupling for Full-Bridge Submodules of a Modular Multilevel Converter

Overmodulation Strategy for Electrolytic Capacitorless PMSM Drives: Voltage Distortion Analysis and Boundary Optimization