Abstract:The flow condensation heat transfer coefficient of R134a inside two helical micro-fin tubes with outer diameter of 6.35 mm and helical angles of 18o and 28o respectively were experimentally studied at a high mass flux ranging from 500 to 1100 kg m−2 s−1. The condensation temperatures are 35°C, 40°C and 45°C, and the vapor qualities ranges from 0.95 to 1.00 at the inlet section and from 0.00 to 0.05 at the outlet section. Experimental results show that there are annular and intermittent flow regimes inside the tube under experimental conditions, the ratio of annular flow region to the total heat transfer region is about 70%. The liquid film flow changes from rotational flow to coexistence of rotational and horizontal flows when the vapor quality is 0.475±0.08, 0.486±0.06 and 0.521±0.05, respectively and the corresponding saturation temperature is 35°C, 40°C and 45°C. Based on the experimental data, the heat transfer coefficient increases with increasing mass flux and fin helical angle, and with decreasing saturation temperature and Reynolds number of cooling water. In addition, the heat transfer coefficient of annular flow is greater than that of intermittent flow, in other words, the heat transfer coefficient increases with increasing vapor quality. The heat transfer coefficient obtained at high mass flux was compared with the calculated data of some published correlations used at low mass flux. It was found that most correlations underestimate the experimental heat transfer coefficient inside the micro-fin tube, and these prediction deviation increases with increasing mass flux and fin helical angle. By introducing some dimensionless numbers as well as considering the flow mechanism of liquid film inside the tube, two heat transfer coefficient correlations were proposed based on the experimental data. The ratio of liquid film thickness to fin height was used to characterize whether the liquid film flow is rotational flow or coexistence of rotational and horizontal flows in the proposed correlation, which shows a better prediction accuracy with a mean deviation of less than 7.3%.

An Experimental Configuration to Study High-Enthalpy Radiating Flows Under Nonequilibrium De-excitation

Numerical study on the non-equilibrium characteristics of high-speed atmospheric re-entry flow and radiation of aircraft based on fully coupled model

Numerical Simulation of Hypersonic Thermochemical Nonequilibrium Flows Using Nonlinear Coupled Constitutive Relations

Visualization of R1233zd(E) Flow Boiling in Parallel Mini-channels

Numerical simulation of non-equilibrium characteristics of high enthalpy shock tunnel nozzle flow

Experimental Study of Condensation Heat Transfer of R134a Inside the Micro-Fin Tubes at High Mass Flux

Numerical study of shock-induced thermochemical nonequilibrium effects in a high Mach flow field

Direct Numerical Simulation of High-Enthalpy Turbulent Boundary-Layer Flow with Light Gas Injections

Heat transfer to a flat plate with arbitrary surface catalysis under partially dissociated nitrogen freestream

Flow and thermal analyses of regenerative cooling in non-uniform channels for combustion chamber

Flow Dynamics in Transient Heat Transfer of N-Decane at Supercritical Pressure

EXPERIMENTAL RESEARCH ON COUPLED HEAT TRANSFER OF A HEAT SOURCE ENCAPSULATED INTO A SUBATMOSPHERIC HYPOBARIC CHAMBER

Nonequilibrium Relaxation in High Speed Flows

Numerical Study of Chemical Non-Equilibrium Effect on Hypersonic Aerodynamic Heating

Investigation of high enthalpy thermochemical nonequilibrium flow over spheres

Design of High-Enthalpy Premixed Supersonic Heater and Experimental Study of Detonation

Numerical Simulation for Hypersonic Flow with High Temperature Thermochemical Nonequilibrium Effect

Aeroheating Study of Hypersonic Chemical Nonequilibrium Flows Around a Reentry Blunt Body

Distributed Flow Calorimetry With Wide Temperature and Pressure Range Based on Scanning Radiation Thermometry

EXPERIMENTAL INVESTIGATION OF HIGHLY EFFECTIVE COOLING WITH AN EVAPORATING ANNULAR FLOW IN A SMALL VERTICAL TUBE

EXPERIMANTAL RESEARCH ON INFRARED RADIATION IN HYPERSONIC FLOW AROUND BLUNT CONE