Experimental Study on the Detection of Frozen Diffused Ammonia Blockage in the Inactive Section of a Variable Conductance Heat Pipe

F. K. Miranda,Romain Rioboo,Mikael Mohaupt,Cristian Marchioli

2023-09-13

Abstract:Variable Conductance Heat Pipes (VCHP) are mainly employed to cool down electronic systems in spacecraft applications, as they can handle high temperature fluctuations in their cold source, preventing thus the systems from damaging. These fluctuations, as well as ultra-low temperatures, are always present in outer space, and one of the key steps in a VCHP design is therefore to make sure that they endure these conditions. However, not much has been written about their resilience during and after a long exposition to subfreezing conditions, i.e. temperatures lower than the freezing point of the working fluid. In this paper we implement and validate a computational routine based on a modified Flat-Front Approach to predict the VCHP temperature profile and to determine the location of the gas-vapor front. Then we continuously expose an ammonia/stainless-steel VCHP to temperatures below the ammonia freezing point for 211 hours, to later examine the formation and subsequent dynamics of a thin block of frozen ammonia which is diffused into the inactive part of the heat pipe condenser. We describe as well how a strong correlation between the adiabatic section and the reservoir temperatures is maintained (or broken) upon the occurrence (or absence) of the blockage of frozen ammonia.

Fluid Dynamics

What problem does this paper attempt to address?

The problem that this paper attempts to solve is how to detect the blockage of thin ice formed by diffusion freezing in variable conductance heat pipes (VCHPs), especially ammonia/stainless - steel VCHPs in spacecraft applications, when exposed to temperatures below the ammonia freezing point for a long time. Specifically, the research focuses on the following aspects:

1. **Description of the diffusion - freezing process**: The paper aims to experimentally study and verify a computational program based on the Modified Flat Front Approach (MFFA) to predict the temperature distribution of VCHPs and determine the position of the gas - vapor interface. This method takes into account the binary mass diffusion phenomenon between vapor and gas due to the presence of non - condensable gas (NCG) under extremely low - temperature conditions.

2. **Experimental verification**: By continuously exposing the ammonia/stainless - steel VCHP to temperatures below the ammonia freezing point for as long as 211 hours, the formation of thin ice and its subsequent dynamic behavior are observed and analyzed. The research pays special attention to how this ice spreads from the active part to the non - active part and its impact on the performance of VCHPs.

3. **Maintenance or disruption of temperature correlation**: The paper explores whether the temperature correlation between the adiabatic section and the reservoir will be broken when ammonia ice blockage occurs. If blockage occurs, the change in the reservoir temperature will no longer cause a corresponding change in the adiabatic section temperature because the expansion of non - condensable gas is hindered by the ice.

4. **Development of detection methods**: Given that the internal situation of VCHPs cannot be directly observed, the paper proposes an indirect method to detect the existence of ice blockage. This method judges whether there is blockage based on the movement of the gas - vapor interface caused by the change in the reservoir temperature and the change in the adiabatic section temperature.

Through the above research, the paper hopes to fill the research gap in the existing literature on the formation of diffusion - freezing blockages in ammonia/stainless - steel VCHPs under extremely low - temperature conditions, provide a scientific basis for the design and management of spacecraft thermal management systems, thereby optimizing the spacecraft's thermal management strategy and reducing unnecessary weight and energy consumption.