Abstract:The authors report on the real-time monitoring of self-limiting aluminum nitride growth process by using multiwavelength in situ ellipsometry. Aluminum nitride (AlN) thin films were grown on Si(100) substrates via hollow-cathode plasma-assisted atomic layer deposition (HCPA-ALD) using trimethylaluminum (TMA) and Ar/N2/H2 plasma as metal precursor and coreactant, respectively. Growth saturation experiments within 100–250 °C temperature range were carried out without interruption as extended single runs featuring 10-cycle subruns for each parameter change. The sensitivity of the multiwavelength ellipsometry provided sufficient resolution to observe not only the minuscule changes in the growth-per-cycle (GPC) parameter, but also the single chemical adsorption (chemisorption) and plasma-assisted ligand removal events. GPC values showed a slight increasing slope within 100–200 °C, followed by a stronger surge at 250 °C, signaling the onset of thermal decomposition. The real-time dynamic in situ monitoring revealed mainly the following insights into the HCPA-ALD process of AlN: (i) film growth rate and TMA chemisorption amount exhibited plasma power dependent saturation behavior, which was also correlated with the substrate temperature; (ii) time-dependent refractive index evolution indicated a nonconstant relationship: a faster increase within the first ∼100 cycles followed by a slower increase as the AlN film gets thicker; and (iii) a considerable improvement in crystallinity was observed when the substrate temperature exceeded 200 °C. Besides in situ optical characterization, ex situ optical, structural, and chemical characterization studies were also carried out on 500-cycle grown AlN films as a function of substrate temperature. All AlN samples displayed a single-phase wurtzite polycrystalline character with no detectable carbon and relatively low (<5%) oxygen content within the bulk of the films. Moreover, regardless of the deposition temperature, HCPA-ALD grown AlN films exhibited highly stoichiometric elemental composition.

Characterization of aluminum nitride thin films by ion beam analysis techniques

Low Temperature Growth of Reactive Partially Ionized Beam Deposited AlN Films

Characterisation of Aluminium Nitride Films and Surface Acoustic Wave Devices for Microfluidic Applications

Reactive Partially Ionized Beam Deposition of Aln Thin Films

XPS studies on AlN thin films grown by ion beam sputtering in reactive assistance of N+/N2+ ions: Substrate temperature induced compositional variations

Real-time in situ ellipsometric monitoring of aluminum nitride film growth via hollow-cathode plasma-assisted atomic layer deposition

Comparison of aluminum nitride thin films prepared by magnetron sputter epitaxy in nitrogen and ammonia atmosphere

High-quality AlN growth: a detailed study on ammonia flow

Preparation of Aln Films by Pulsed Laser Deposition Using Sintered Aluminum Nitride and Elemental Aluminum As Raw Materials

Low temperature aluminum nitride thin films for sensory applications

Low-temperature Synthesis of AlN Films Through Electron Cyclotron Resonance Plasma-Aided Reactive Pulsed Laser Deposition

Preparation of Aln Thin Films for Film Bulk Acoustic Resonator Application by Radio Frequency Sputtering

Study of preparation of AlN Thin Films for FBAR Application by RF Sputtering

Structural, chemical and optical characterizations of nanocrystallized AlN:Er thin films prepared by r.f. magnetron sputtering

Optical and Structural Properties of Aluminum Nitride Epi-Films at Room and High Temperature

Study On the Uniformity Aluminum Nitrate Thin Film On 2-Inch Silicon Substrate Prepared by RF Magnetron Sputtering

Growth of AIN Films by RF Reactive Magnetron Sputtering for Film-Bulk-Acoustic-Wave-Resonator Fabrication

Surface chemistry in atomic layer deposition of AlN thin films from Al(CH3)3 and NH3 studied by mass spectrometry

Structure and Electrical Conductivity of Thin AlN Films on Si

Low temperature growth of c-axis oriented AlN films on γ-LiAlO2 by radio frequency magnetron sputtering

Low-Temperature Deposition of AlN Films\+*