Abstract:The revival of CO2 methanation (Sabatier reaction) as part of the large-scale Power-to-Gas technology has stimulated the development of novel reactor concepts for better heat management due to its exothermic nature. The generation of hot-spots in fixed bed reactors could reduce methane yield, accelerate catalyst deactivation, and potentially cause thermal runaway. However, hot-spots could be utilized to achieve outstanding CO2 methanation performance at low temperatures and high gas flow rate in monolithic reactors, whereas strategic bed packing configurations could boost the performance of low-activity catalytic beds. We prepared NiFe catalysts derived from in-situ grown layered double hydroxides via urea hydrolysis on washcoated cordierite honeycomb substrate with varying activities. Temperature profiles by both experimental and computational fluid dynamic (CFD) studies revealed hot-spot formation along catalytic beds. Hot-spots increased the catalytic beds' temperature due to high thermal conductivity of cordierite monolith, thus accelerated the reaction. The monolithic reactor with a single-monolith bed exhibited a methane yield of 16.5% at 250 degrees C, which was significantly increased to 80.4% on the reactor with three-monolith bed of the same catalyst at similar reaction condition with a constant ratio of catalyst mass to gas flow rate. A combined low-high activity monolithic bed was proposed which demonstrated high methane yield and excellent stability. Interestingly, the methane yields were higher at a gas flow rate of 1500 mL/min than that at 500 mL/min, again ascribed to the beneficial effect of hot-spot formation on monolithic reactors. Therefore, strategic bed packing configuration plays an important role in the optimization of monolithic methanation reactors, and hot-spot formation could be exploited to achieve excellent CO2 methanation performance at low temperatures.

Characteristics of integral plasma-fluidized bed and preparation of Mo-based catalysts for sulfur-resistant methanation

Effect of DBD plasma treatment on activity of Mo‐based sulfur‐resistant methanation catalyst

Methanol to Propylene over Foam SiC-Supported ZSM-5 Catalyst: Performance of Multiple Reaction–Regeneration Cycles

Dry reforming of methane in an atmospheric pressure plasma fluidized bed with Ni/γ-Al2O3 catalyst

Plasma Treatment of Ni Catalyst for Partial Oxidation of Methane

Preparation and Characterization of A Plasma Treated Nimgsba-15 Catalyst for Methane Reforming with Co2 to Produce Syngas

Efficient plasma-catalysis coupling for CH4 and CO2 transformation in a fluidized bed reactor: Comparison with a fixed bed reactor

Reaction Characteristics of Ni-Based Catalyst Supported by Al2O3 in a Fluidized Bed for CO2 Methanation

Dry Reforming of Methane in A Dielectric Barrier Discharge Reactor with Ni/Al2o3 Catalyst: Interaction of Catalyst and Plasma

Application of In-Plasma Catalysis and Post-Plasma Catalysis for Methane Partial Oxidation to Methanol over a Fe2O3-CuO/γ-Al2O3 Catalyst

Combination of CO 2 reforming and partial oxidation of CH 4 over Ni/Al 2 O 3 catalysts using fluidized bed reactor

Bed Packing Configuration and Hot-Spot Utilization for Low-Temperature CO2 Methanation on Monolithic Reactor

A Monolith CuNiFe/γ-Al2O3/Al Catalyst for Steam Reforming of Dimethyl Ether and Applied in a Microreactor

Bubble dynamics and thermochemical characteristics of bubbling fluidized bed methanation

Coupling of Dielectric Barrier Discharge and Cu–S-1 Catalyst for Direct Oxidation of Methane to Methanol

Research Progress in Fluidized Bed Methanation Technology

Methane Dry Reforming over Ni/Al2O3 Catalyst in Spark Plasma Reactor: Linking Computational Fluid Dynamics (CFD) with Reaction Kinetic Modelling

Solution Plasma-Assisted Preparation of Highly Dispersed NiMnAl-LDO Catalyst to Enhance Low-Temperature Activity of CO2 Methanation

Direct Oxidation of Methane to Methanol over Cu-Based Catalyst in an AC Dielectric Barrier Discharge

Cu-Zr-Zn catalysts for methanol synthesis in a fluidized bed reactor

Direct Conversion of Methane Over Oxide-Type Catalysts Supported on Mesoporous Silica Under Electric Discharge