Abstract:Mg-Zn alloys form the basis of a wide variety of commercial light-weight Mg alloys due to their precipitation hardenability, biocompatibility, and low cost. Despite significant progress, there exist controversies over the crystal structures and stabilities of various complex precipitates in this important binary system. In this work, the information about crystal structures and stabilities of phases in Mg-Zn system is critically reviewed and three key open questions are identified: (1) What are crystal structures of Guinier-Preston (GP) zones? (2) What are relative stabilities of a myriad of phases observed for β1′ precipitates? (3) Why does the β2′ phase have two distinct orientation relationships (ORs) with α-Mg? To shed light on these questions, comprehensive first-principles calculations based on density functional theory, cluster expansion, and Monte Carlo simulations are performed. The atomic structures of GP zones are predicted, and the effect of coherency strain on their stabilities are analyzed. The structures of β1′precipitates composed of the rhombic MgZn2 and the elongated hexagonal Mg6Zn7 units are provided. It is shown that the β1′precipitate can be stabilized with increased fraction of rhombic MgZn2 units, which leads to local regions of the C14 MgZn2 Laves phase. The origin of the two distinct ORs between β2′ phase and the matrix is traced back to two formation paths, i.e., relaxation of the coherent Zn ordering on HCP matrix and coarsening of C14 MgZn2 region in β1′precipitates. Finally, a feasible precipitation sequence in Mg-Zn alloys is suggested.

The bi-layered precipitate phase zeta in the Al-Ag alloy system

Evolution of Precipitate and Precipitate/matrix Interface in Al-Zn-Mg-Cu(-Ag)alloys

Atomic-scale study on the precipitation behavior of an Al-Zn-Mg-Cu alloy during isochronal aging

Revisiting the precipitation mechanisms of Guinier-Preston zones, η′, and η precipitates in Al-Zn-Mg alloys

Early Stages of Precipitation in Γ' Phase of a Ni–Al–Ti Model Alloy: Phase-Field and First-Principles Study

Experimental Characterization and First-Principles Calculations of Zn Segregation at the Β″-Mg5al2si4/al Interfaces in Al-Mg-Si Alloys

Crystal structure and stability of phases in Mg-Zn alloys: A comprehensive first-principles study

Nucleation and growth of the γ' (AlAg2) precipitate in Al-Ag(-Cu) alloys

Microstructure and Precipitates in Mg-Zn-Y Alloys

Atomic-scale computer simulation of mixture precipitation mechanism for Ni75AlxV25-x alloy

COMPUTER SIMULATION FOR PRECIPITATION PROCESSO Ni_<75>Al_<2.5>V_<22.5> ALLOY WITH THE MICROSCOPIC PHASE-FIELD METHOD

Nucleation and evolution mechanism of precipitates during the initial aging stage in Al-Zn-Mg-Cu alloy

Investigation of Atomic-Scale η1 Precipitate Growth in Aluminum-Zinc-Magnesium Alloys

Transmission Electron Microscopy Study of the Early-Stage Precipitates in Al-Mg-Si Alloys

Fine precipitation scenarios of AlZnMg(Cu) alloys revealed by advanced atomic-resolution electron microscopy study Part I: Structure determination of the precipitates in AlZnMg(Cu) alloys

Precipitation in Al-Zr-Sc alloys: a comparison between kinetic Monte Carlo, cluster dynamics and classical nucleation theory

On chemical order and interfacial segregation in $γ^\prime$ (AlAg$_2$) precipitates

Thermodynamic description of the Al–Ag–Zr system and discovery of the high-strength ternary phase Al1.84Ag0.16Zr

First principles analysis of precipitation in Mg-Zn alloys

Precipitation behavior in the early stage of aging in an Al–Li°Cu–Mg–Zr–Ag (Weldalite 049) alloy

Precipitation and crystallographic relationships of nanosized η/η’ precipitates at S-Al interface in Al-Zn-Mg-Cu alloy