Abstract:A 20 L hollow-fiber submerged anaerobic membrane bioreactor (SAnMBR) was used to treat real domestic wastewater at 25 °C with hydraulic retention times (HRTs) ranging from 4 to 12 h. The process performance was evaluated by organic removal efficiency, biogas production, sludge yield, and filtration behaviors during one-year's operation. For HRTs ranging between 6 and 12 h, the AnMBR showed good organic removal efficiency with chemical oxygen demand (COD) and biochemical oxygen demand (BOD) removal efficiencies of about 89% and 93%, respectively. The biogas yield was 0.26 L-gas/g-CODfed, with approximately 80% methane content, and the sludge yield was 0.07–0.11 g-VSS/g-CODrem. While at an HRT of 4 h, with the higher wastewater treatment capacity and organic loading rate (OLR), the biogas production was lower (0.17 L-gas/g-CODfed), and the sludge production was higher (0.22 g-VSS/g-CODrem). The organic removal performance (COD 84% and BOD 89%) at HRT of 4 h was acceptable due to the effective separation effect of the membrane filtration process. According to COD balance analysis, the low biogas yield and high sludge yield at HRT of 4 h were due to insufficient biodegradation under an OLR of 2.05 g-COD/L-reactor/d. Theoretical calculations based on Henry's law indicate that the ideal methane content in the biogas should be 82–85% when the operational temperature was 25 °C. To achieve a high flux and sustainable AnMBR operation, the impact of mixed liquor suspended solid (MLSS) and gas sparging velocity (GSV) on the filtration performance was analyzed. The critical flux increased with increase in the GSV from 24.2 to 174.3 m/h, but decreased with increase in the MLSS concentration from 8.2 to 20.2 g/L. Therefore, decreasing fouling rate to 0.8–1.2 kPa/d by efficiently controlling GSV and MLSS, sustainable operation could be achieved at a flux of 0.34 m/d.

Seasonal temperatures impact on the mass flows in the innovative integrated process of anaerobic membrane bioreactor and one-stage partial nitritation-anammox for the treatment of municipal wastewater

Performance of anammox UASB reactor treating low strength wastewater under moderate and low temperatures

Biomass retention and microbial segregation to offset the impacts of seasonal temperatures for a pilot-scale integrated fixed-film activated sludge partial nitritation-anammox (IFAS-PN/A) treating anaerobically pretreated municipal wastewater

Influence of seasonal temperature fluctuations on two different partial nitritation-anammox reactors treating mainstream municipal wastewater

Treating the filtrate of mainstream anaerobic membrane bioreactor with the pilot-scale sludge-type one-stage partial nitritation/anammox process operated from 25 to 15 °C

Pilot plant demonstration of temperature impacts on the methanogenic performance and membrane fouling control of the anaerobic membrane bioreactor in treating real municipal wastewater

Achieving low-carbon municipal wastewater treatment by anaerobic membrane bioreactor at seasonal temperatures: A pilot scale investigation on reducing sludge yield and greenhouse gas emissions

Deciphering the effect of temperature reduction on the biofilm in partial nitritation-anammox system: Insights from microbial community to metabolic pathways

Important effects of temperature on treating real municipal wastewater by a submerged anaerobic membrane bioreactor: Removal efficiency, biogas, and microbial community

Robustness of Granular Activated Carbon-Synergized Anaerobic Membrane Bioreactor for Pilot-Scale Application over a Wide Seasonal Temperature Change

[Performance and Process Kinetics of Pilot-Scale ANAMMOX Bioreactor under Different Water Temperatures].

Operating characteristics of anaerobic membrane bioreactor for domestic wastewater treatment under ambient temperature

Submerged anaerobic membrane bioreactor applied for mainstream municipal wastewater treatment at a low temperature: Sludge yield, energy balance and membrane filtration behaviors

One-year operation of a 20-L submerged anaerobic membrane bioreactor for real domestic wastewater treatment at room temperature: Pursuing the optimal HRT and sustainable flux

Effect of low temperature on the performance of a gravity flow CANON-like pilot plant MBR treating surface water

Mainstream partial denitrification-anammox (PD/A) for municipal sewage treatment from moderate to low temperature: Reactor performance and bacterial structure

The running performances of combined process of CEPT-MBBR in different temperatures

Response of partial nitritation-anammox process to substrate concentration and temperature variations in a single-stage airlift circulation system: Performance and microbial community dynamics

Sludge yield and degradation of suspended solids by a large pilot-scale anaerobic membrane bioreactor for the treatment of real municipal wastewater at 25 °C

Seasonal and annual energy efficiency of mainstream anaerobic membrane bioreactor (AnMBR) in temperate climates:Assessment in onsite pilot plant and estimation in scaled-up plant

Pilot-scale Research on Treatment of Municipal Wastewater by Two-stage MBBR at Low Temperature