Abstract:This paper reports a CFD numerical study of propane (C3H8) combustion inside a laboratory-scale cylindrical furnace under moderate or intense low oxygen dilution (MILD) regime. The reliability of the present numerical simulation was firstly validated against previous experiment (Energy & Fuels, 2018, 32(8): 8817–8829), and the C3H8 MILD combustion characteristics were thoroughly examined through a comparison with its traditional combustion counterpart, in terms of temperature distribution, heat release behavior, CO formation, and NO formation as well as reduction mechanisms. The results show that, MILD combustion produces a lower overall heat flux on furnace walls than traditional combustion, while the proportion of convection heat transfer increases remarkably, suggesting the different heat transfer behaviors between the two combustion modes. In addition, both MILD and traditional combustion modes exhibit only the positive heat release region inside the furnace, however, C3H8 consumption pathway indicates that traditional combustion features strong C3H8 pyrolysis in the early ignition stage (x = 80 mm), which is not found in MILD combustion. Moreover, the formation of CO in traditional combustion is dominated by the oxidation of larger hydrocarbon molecule in the intense reaction region (x = 240 mm), while CO in MILD combustion comes from the oxidation of smaller hydrocarbon molecules in both early ignition and intense reaction regions, showing its volumetric reaction feature. Furthermore, the relative contributions of the prompt route as well as the N2O and NNH intermediate routes to final NO emission are enhanced in MILD combustion comparing to those in traditional combustion, however, these routes still can be neglected in both traditional and MILD combustion due to their significantly low yields. For NO reduction, reburning route plays a more important role than SNCR route in both traditional and MILD combustion, and is even more profound in the latter. Overall, thermal-route still dominates the NO formation for both combustion modes in the present furnace.

Experimental study on MILD combustion of methane under non-preheated condition in a swirl combustion furnace

Numerical analysis of the effect of swirl angle and fuel equivalence ratio on the methanol combustion characteristics in a swirl burner

MILD combustion of methane in a model combustor with an inverse-diffusion flame configuration

Effect of thermal input, excess air coefficient and combustion mode on natural gas MILD combustion in industrial-scale furnace

Progress and recent trend in MILD combustion

Numerical study of fuel-NO formation and reduction in a reversed flow MILD combustion furnace firing ammonia-doped methane

MILD Combustion under Different Premixing Patterns and Characteristics of the Reaction Regime

Experimental And Numerical Study On Moderate Or Intense Low-Oxygen Dilution Oxy-Combustion Of Methane In A Laboratory-Scale Furnace Under N-2, Co2, And H2o Dilutions

Experimental investigation of the characteristics of combustion in the full hydrogen blending range of methane-hydrogen mixtures in a MILD model combustor

Experimental Investigation on Co-Firing Residual Char and Pulverized Coal under MILD Combustion Using Low-Temperature Preheating Air

Stability and emission characteristics of nonpremixed MILD combustion from a parallel-jet burner in a cylindrical furnace

Experimental Investigation of Low-Temperature Autoignition in Turbulent Premixed Swirling Flames

Nonpremixed MILD Combustion in a Laboratory-Scale Cylindrical Furnace: Occurrence and Identification

Effects of Reactant Injection Conditions on Diffusion Combustion of Natural Gas in a Laboratory-scale Combustor

Moderate or Intense Low-Oxygen Dilution Oxy-combustion Characteristics of Light Oil and Pulverized Coal in a Pilot-Scale Furnace

Numerical simulation of propane MILD combustion in a lab-scale cylindrical furnace

Numerical Simulation of Flameless Premixed Combustion with an Annular Nozzle in A Recuperative Furnace

Effect of equivalence ratio and staging ratio on the methane MILD combustion in dual-stage combustor

A Novel Method to Improve Stability of MILD Combustion in a Highly Heat-Extracted Furnace

MILD Combustion of Solid Fuels: Its Definition, Establishment, Characteristics, and Emissions

Diffusion MILD Combustion of Firing Pulverized-coal at a Pilot Furnace