Abstract:Combinations of nanoparticles and surfactants have been widely employed in many industrial processes, i.e., boiling and condensation in heat transfer and hydraulic fracturing in shale oil and gas production, etc. However, the underlying mechanism for various phenomena resulting from the addition of nanoparticles into the surfactant solutions is still unclear. For instance, there are contradictory conclusions from the literature regarding the variations of surface tension upon the addition of nanoparticles into surfactant solutions. In this work, the dominating factors determining if the surface activity of the surfactant solution will increase or conversely decrease when adding certain kinds of nanoparticles have been investigated. Two typical hydrophilic nanoparticles, SiO2 and TiO2 with anionic or cationic surfactants, respectively, have been considered. The surface tension has been measured in a wide range of nanoparticle and surfactant concentrations. It was found that the surface tension of the ionic surfactant solution can be further reduced only if nanoparticles of the same charge were added. For instance, a system containing 0.25 CMC SDS and 1 wt% SiO2 behaves similar to a 0.34 CMC SDS-only solution. Interestingly, the observed synergistic effect is found to be more significant if the surfactant concentration is much lower than its CMC for a given nanoparticle content. Moreover, the effect is perfectly reversible. When the nanoparticles were separated from the system, the surface tension values recovered fully to that of the pure surfactants. If nanoparticles of opposite charge were added, however, the surface tension of the surfactant solution increased. Zeta potential measurement and centrifugal treatment have been employed to reveal the interplay between nanoparticles and surfactants and the adsorption behavior of their assemblies at the liquid/air interface. Based on the experimental outcomes, a possible physical mechanism was proposed. It was concluded that the electrostatic repulsion between surfactant molecules and nanoparticles should be the dominant factor responsible for the observed reversible synergistic effect. Our study is expected to contribute to a better understanding of the interfacial phenomenon in nanoparticle-surfactant complex systems.

New insight into surface adsorption thermodynamic, kinetic properties and adsorption mechanisms of sodium oleate on ilmenite and titanaugite

Adsorption of polystyrenesulfonate on titanaugite surface: Experiments and quantum chemical calculations

Adsorption performance and mechanism of the commonly used collectors with Oxygen-containing functional group on the ilmenite surface: A DFT study

A novel sodium trans-2-nonene hydroxamate for the flotation separation of ilmenite and forsterite: Superior collecting and selectivity

Quantitative analysis of surface adsorption reactivity during flotation process by surface complexation model: diaspore and kaolinite

Insights into the influence of calcium ions on the adsorption behavior of sodium oleate and its response to flotation of quartz: FT-IR, XPS and AMF studies

Insights into the selective adsorption mechanism of a multifunctional thioether-containing hydroxamic acid on separation of wolframite from fluorite

Elucidating the enhancement of kaolinite flotation by iron content through density functional theory: A study on sodium oleate adsorption efficiency

Novel insights into the influence of ferric ion as a surface modifier to enhance the floatability of specularite

Novel insights into the microstructure of Al-BHA on the surface of ilmenite

FTIR internal reflection spectroscopy studies of the effect of pH on adsorption of oleate/oleic acid at the surface of a TiO2 thin film deposited on a Ge single crystal

Surface complexation model theory application in NaOL and CTAB collector adsorption differences of diaspore and kaolinite flotation

Adsorption Mechanism of New Mixed Anionic/cationic Collectors in a Spodumene-Feldspar Flotation System

The effect of selective adsorption of dissolved aegirite species on the separation of specularite and aegirite

Surface modification of ilmenite by introducing copper-ammonia ion and its response to flotation in H2SO4-H2O2 system

Toward an Enhanced Hydrophilic TiO2 Nanoparticles Adsorption at Air-Liquid Interface Through Ion Regulation.

Depression effect of acid surface pretreatment on the flotation behaviors of four classified titanaugites

Investigations on the synergistic effect of combined NaOl/SPA collector in ilmenite flotation

Effect of Pre-Sulfidization on the Octadecyl Amine Adsorption on the Smithsonite Surface and Its Flotation

Direct imaging and mechanism study of C6 α-olefin adsorption on faujasite and Linde Type A zeolites

Insights into the Complex Interaction Between Hydrophilic Nanoparticles and Ionic Surfactants at the Liquid/air Interface.