Abstract:We demonstrate the efficacy of wave-interference-based light trapping and carrier transport in parabolic-pore photonic-crystal, thin-crystalline silicon (c-Si) solar cells to achieve above 29% power conversion efficiencies. Using a rigorous solution of Maxwell’s equations through a standard finite-difference time domain scheme, we optimize the design of the vertical-parabolic-pore photonic crystal (PhC) on a 10-μm-thick c-Si solar cell to obtain a maximum achievable photocurrent density (MAPD) of 40.6 mA/cm2 beyond the ray-optical, Lambertian light-trapping limit. For a slanted-parabolic-pore PhC that breaks x-y symmetry, improved light trapping occurs due to better coupling into parallel-to-interface refraction modes. We achieve the optimum MAPD of 41.6 mA/cm2 for a tilt angle of 10° with respect to the vertical axis of the pores. This MAPD is further improved to 41.72 mA/cm2 by introducing a 75-nm SiO2 antireflective coating on top of the solar cell. We use this MAPD and the associated charge-carrier generation profile as input for a numerical solution of Poisson’s equation coupled with semiconductor drift-diffusion equations using a Shockley-Read-Hall and Auger recombination model. Using experimentally achieved surface recombination velocities of 10 cm/s, we identify semiconductor doping profiles that yield power conversion efficiencies over 29%. Practical considerations of additional upper-contact losses suggest efficiencies close to 28%. This improvement beyond the current world record is largely due to an open-circuit voltage approaching 0.8 V enabled by reduced bulk recombination in our thin silicon architecture while maintaining a high short-circuit current through wave-interference-based light trapping.

Synergistic plasmonic and photonic crystal light-trapping: Architectures for optical up-conversion in thin-film solar cells

Optical design of organic solar cell with hybrid plasmonic system.

High Performance Ultrathin Silicon Solar Microcells Enabled With Nanophotonic Light Management And Spectral Upconversion

Surface Plasmon Enhancement of Optical Absorption in Thin-Film Silicon Solar Cells

Down Converter Device Combining Rare-Earth Doped Thin Layer and Photonic Crystal for c-Si Based Solar Cell

High‐Performance Flexible Nanostructured Silicon Solar Modules with Plasmonically Engineered Upconversion Medium

Photocurrent Enhancement In Plasmonic Solar Cells Attached To Luminescent Solar Concentrators

High-efficiency photonic crystal solar cell architecture

Single crystal monolithic up-converter solar cell device tandems with integrated optics

Absorption enhancement using photonic crystals for silicon thin film solar cells

Designing High-Efficiency Thin Silicon Solar Cells Using Parabolic-Pore Photonic Crystals

Nano-Photonic Structures for Light Trapping in Ultra-Thin Crystalline Silicon Solar Cells

Adding A Thin Metallic Plasmonic Layer to Silicon Thin Film Solar Cells

Broadband Absorption Enhancement Achieved by Optical Layer Mediated Plasmonic Solar Cell

Semiconductor plasmon-sensitized broadband upconversion and its enhancement effect on the power conversion efficiency of perovskite solar cells

Progress in thin-film silicon solar cells based on photonic-crystal structures

Highly Efficient LiYF4:Yb3+, Er3+ Upconversion Single Crystal under Solar Cell Spectrum Excitation and Photovoltaic Application

Strategically Manipulated Polymer Solar Cells to Incorporate Plasmonically Enhanced Spectral Upconversion Backplane

Inverse Optical Cavity Design for Ultrabroadband Light Absorption Beyond the Conventional Limit in Low‐Bandgap Nonfullerene Acceptor–Based Solar Cells

Plasmon-Enhanced Light Harvesting of Chlorophylls on Near-Percolating Silver Films Via One-Photon Anti-Stokes Upconversion