Abstract:Thin film silicon solar cells are believed to be promising candidates for continuing cost reduction in photovoltaic panels because silicon usage could be greatly reduced. Since silicon is an indirect bandgap semiconductor, its absorption coefficient is low for photons in the wavelength ranges between 600nm and 1100nm. For high efficiency thin film modules, effective light trapping is essential. Traditional schemes such as textured transparent conductive oxide (TCO) and metal reflector have several disadvantages such as enhanced surface recombination, parasitic losses at the TCO/metal interface, and the lack of ability to control and optimize the textured surface. We have previously proposed to employ a light trapping structure, which combines a self-assembled submicron grating and a distributed Bragg reflector (DBR) on the backside of thin film silicon solar cells. The DBR works as a one-dimensional photonic crystal to obtain almost 100% reflectivity. The grating scatters the incident light into oblique angles to significantly enhance the optical path length. Numerical calculations predict that by optimizing the feature sizes of the grating and DBR, up to 31% relative efficiency increase can be obtained, compared to the bare thin film Si. By using self-assembly, the organized grating structure can be formed spontaneously at a much lower cost. Current-voltage relations and quantum efficiency measurements were taken to verify the performance of our designed back structure. In the wavelength range of 600-900nm, photon absorption is greatly enhanced. As a result, more than 20% relative efficiency enhancement is achieved for 1.5um thin film silicon cells. These numerical and experimental results show that a light trapping design can be low-cost and increase efficiencies for high performance thin film Si solar cells.

High-efficiency photonic crystal solar cell architecture

Improving thin-film crystalline silicon solar cell efficiencies with photonic crystals

Progress in thin-film silicon solar cells based on photonic-crystal structures

Designing High-Efficiency Thin Silicon Solar Cells Using Parabolic-Pore Photonic Crystals

Towards 30% Power Conversion Efficiency in Thin-Silicon Photonic-Crystal Solar Cells

Absorption enhancement using photonic crystals for silicon thin film solar cells

Nano-Photonic Structures for Light Trapping in Ultra-Thin Crystalline Silicon Solar Cells

Nanoimprint Photonic Crystal Film Enhanced Light-Trapping in a-Si Thin Film Solar Cells

Absorbing photonic crystals for silicon thin-film solar cells: Design, fabrication and experimental investigation

Thin-film silicon solar cells: photonic design, process and fundamentals

Efficient Light Trapping Structure in Thin Film Silicon Solar Cells

Synergistic plasmonic and photonic crystal light-trapping: Architectures for optical up-conversion in thin-film solar cells

Investigation on Significant Efficiency Enhancement of Thin Crystalline Silicon Solar Cells

Enhanced Efficiency in Thin Film Solar Cells: Optimized Design With Front Nanotextured and Rear Nanowire-Based Light Trapping Structure

Photonic Crystal Structures for Light Trapping in Thin-Film Si Solar Cells: Modeling, Process and Optimizations

Electro-Optical Simulation Of In Ultra-Thin Photonic Crystal Amorphous Silicon Solar Cells

Effects of frequency upconversion layer and two-dimensional arrays of inverted nanocone hole on the performance of ultrathin crystalline silicon solar cells

Advance in photonic crystal solar cells

Silicon Periodic Nanostructures for High Efficiency Absorption in Thin Film Solar Cells

High-efficiency ultra-thin GaAs solar cells based on ITO/Ag/ITO transparent electrodes and photonic crystals