Abstract:The rising generation of waste activated sludge (WAS) demands a fundamental shift towards resource reuse and recovery. The conventional methodologies used to manage this by-product derived from wastewater treatment plants are increasingly constrained due to stringent regulatory measures aimed at mitigating its adverse impacts on the environment and public health. Therefore, this work evaluated a promising strategy for the efficient management of WAS, transforming it into a valuable renewable source to produce high-value-added compounds, such as lipids and a slow-release fertilizer (struvite). Wet oxidation (WO) was identified as a suitable technique for solubilising WAS while generating short-chain fatty acids (primarily acetic acid). It was found that conducting WO at 200 °C for 120 min resulted in a 65% reduction of the total suspended solids (TSS) content and 87% of the volatile suspended solids (VSS) content. Additionally, under these conditions, 4440 ± 105 mg/L and 593 ± 21 mg/L of acetic and propionic acid were obtained, respectively, which were assimilated by Yarrowia lipolytica to produce biolipids. Furthermore, the rupture of WAS flocs also led to the solubilisation of 980 ± 8 mg/L of ammonium. During the struvite precipitation stage, a NH4:PO4:Mg ratio of 1:1.5:1.5 was found to be the most effective for removing soluble ammonium (97.4 ± 0.8%), resulting in a high-purity struvite formation, and enhancing the carbon/nitrogen (C/N) ratio of the oxidised WAS from 3 to 105. This improvement in the C/N ratio raised the lipid content from 36 ± 1% to 49 ± 1% during the cultivation of Y. lipolytica. The application of the sequencing batch culture strategy further increased lipid content to 59 ± 1%, with 6.0 ± 0.3 g/L as the final concentration after the fifth cycle. The lipids produced, mainly monounsaturated fatty acids with 40% of oleic acid, offer potential as biodiesel feedstock. This lipid composition led to biodiesel properties, including cetane number, iodine value, kinematic viscosity and density that met international standards. Therefore, this research presents a promising alternative not only for WAS management but also for harnessing valuable resources, thereby establishing a basis for large-scale studies.

Unravelling the secrets of a landfill for municipal solid waste (MSW): Lipid-to-biodiesel production by the new strain Chlorella vulgaris DSAF isolated from leachates

In Situ Ethyl Ester Production from Wet Algal Biomass under Microwave-Mediated Supercritical Ethanol Conditions

Preliminary Evaluation of a Newly Isolated Microalga Scenedesmus Sp. CHX1 for Treating Landfill Leachate

A two-stage culture process using Chlorella vulgaris for urban wastewater nutrient removal and enhanced algal lipid accumulation under photoautotrophic and mixotrophic conditions

Green microalgal strain Chlorella vulgaris isolated from industrial wastewater with remediation capacity

Enzymatic Ethanolysis Subjected to Schizochytrium Biomass: Sequential Processing for DHA Enrichment and Biodiesel Production

Orthogonal Optimization Of A Newly Isolated Microalga Desmodesmus Sp.-Chx1 As A Potential Candidate For Biodiesel Production

Cultivation of Chlorella vulgaris in wastewater: biodiesel potential and wastewater remediation

Biorefinery of waste activated sludge: Nutrient recovery and microbial lipid production by Yarrowia lipolytica

Enhancement of productivity of <i>Chlorella pyrenoidosa</i> lipids for biodiesel using co-culture with ammonia-oxidizing bacteria in municipal wastewater

Enhanced energy recovery from landfill leachate by linking light and dark bio-reactions: Underlying synergistic effects of dual microalgal interaction

Utilization of Chlorella Biomass Grown in Waste Peels-Based Substrate for Simultaneous Production of Biofuel and Value-Added Products Under Microalgal Biorefinery Approach

Microalgal lipids production and nutrients recovery from landfill leachate using membrane photobioreactor

Microalgae on distillery wastewater treatment for improved biodiesel production and cellulose nanofiber synthesis: A sustainable biorefinery approach

A synergic approach for nutrient recovery and biodiesel production by the cultivation of microalga species in the fertilizer plant wastewater

Nutrients recovery from dairy wastewater by Chlorella vulgaris and comparison of the lipid’s composition with various chlorella strains for biodiesel production

Growing Chlorella Vulgaris on Mixed Wastewaters for Biodiesel Feedstock Production and Nutrient Removal

Coupling wastewater treatment, biomass, lipids, and biodiesel production of some green microalgae

Sustainable Biodiesel Production via Chlorella vulgaris and Tetraselmis Chuii in Food-based Brewery Industrial Wastewater

Microalgae biomass pre-treatment with deep eutectic solvent to optimize lipid isolation in biodiesel production

High-efficiency nutrients reclamation from landfill leachate by microalgae Chlorella vulgaris in membrane photobioreactor for bio-lipid production