Abstract:Marine microalga Nannochloropsis is a promising source for the production of renewable and sustainable biodiesel in replacement of depleting petroleum. Other than biodiesel, Nannochloropsis is a green and potential resource for the commercial production of nutraceutical eicosapentaenoic acid (EPA, C20:5). In recent studies, low-value biodiesel can be achieved by transesterification of Nannochloropsis biomass. However, it is undoubtedly wasteful to produce microalgal biodiesel containing EPA from nutritional and economical aspects. A new strategy was addressed and exploited to produce low-value bulky biodiesel along with EPA enrichment via enzymatic ethanolysis of Nannochloropsis biomass with a specific lipase. Cellulase pretreatment on Nannochloropsis sp. biomass significantly improved the biodiesel conversion by direct ethanolysis with five enzymes from Candida antarctica (CALA and CALB), Thermomyces lanuginosus (TL), Rhizomucor miehei (RM), and Aspergillus oryzae (PLA). Among these five biocatalysts, CALA was the best suitable enzyme to yield high biodiesel conversion and effectively enrich EPA. After optimization, the maximum biodiesel conversion (46.53–48.57%) was attained by CALA at 8:1 ethanol/biomass ratio (v/w) in 10–15% water content with 10% lipase weight at 35 °C for 72 h. Meanwhile, EPA (60.81%) was highly enriched in microalgae NPLs (neutral lipids and polar lipids), increasing original EPA levels by 1.51-fold. Moreover, this process was re-evaluated with two Nannochloropsis species (IMET1 and Salina 537). Under the optimized conditions, the biodiesel conversions of IMET1 and Salina 537 by CALA were 63.41% and 54.33%, respectively. EPA contents of microalgal NPLs were 50.06% for IMET1 and 53.73% for Salina 537. CALA was the potential biocatalyst to discriminate against EPA in the ethanolysis of Nannochloropsis biomass. The biodiesel conversion and EPA enrich efficiency of CALA were greatly dependent on lipidic class and fatty acid compositions of Nannochloropsis biomass. CALA-catalyzed ethanolysis with Nannochloropsis biomass was a promising approach for co-production of low-value biodiesel and high-value microalgae products rich in EPA.

In Situ Ethyl Ester Production from Wet Algal Biomass under Microwave-Mediated Supercritical Ethanol Conditions

Subcritical water extraction of lipids from wet algae for biodiesel production

In Situ Enzymatic Conversion of Nannochloropsis oceanica IMET1 Biomass into Fatty Acid Methyl Esters

Current Progress and Future Perspective of Microalgae Biomass Pretreatment Using Deep Eutectic Solvents

Enzymatic Ethanolysis Subjected to Schizochytrium Biomass: Sequential Processing for DHA Enrichment and Biodiesel Production

A novel rapid ultrasonication-microwave treatment for total lipid extraction from wet oleaginous yeast biomass for sustainable biodiesel production

Using wet microalgae for direct biodiesel production via microwave irradiation

A Novel Clean Process for the Combined Production of Fatty Acid Ethyl Esters (faees) and the Ethyl Ester of Polyunsaturated Fatty Acids (pufas) from Microalgae Oils

Optimization of microwave assisted lipid extraction from microalga Scenedesmus obliquus grown on municipal wastewater

Microalgae biomass pre-treatment with deep eutectic solvent to optimize lipid isolation in biodiesel production

Hydrothermal microwave processing of microalgae as a pre-treatment and extraction technique for bio-fuels and bio-products

Microalgal synthesis of the biodiesel employing simultaneous extraction and esterification via heterogeneous catalyst

New insights to direct conversion of wet microalgae impregnated with ethanol to biodiesel exploiting extraction with supercritical carbon dioxide

A Novel Process on Lipid Extraction from Microalgae for Biodiesel Production

In Situ Transesterification of Microalgae with High Free Fatty Acid Using Solid Acid and Alkali Catalyst.

Combined Enzymatic and Mechanical Cell Disruption and Lipid Extraction of Green Alga Neochloris oleoabundans

Lipid Production Through the Single-Step Microwave Hydrolysis of Macroalgae Using the Oleaginous Yeast Metschnikowia Pulcherrima

Direct Enzymatic Ethanolysis of Potential Nannochloropsis Biomass for Co-Production of Sustainable Biodiesel and Nutraceutical Eicosapentaenoic Acid

Biodiesel from wet microalgae: extraction with hexane after the microwave-assisted transesterification of lipids.

Cost-effective biodiesel production from wet microalgal biomass by a novel two-step enzymatic process.

Efficient Biodiesel Conversion From Microalgae Oil Of Schizochytrium Sp.