Abstract:Water reuse is a safe and often the least energy-intensive method of providing water from non-conventional sources in water stressed regions. Although public perception can be a challenge, water reuse is gaining acceptance. Recent advances in membrane technology allow for reclamation of wastewater through the production of high-quality treated water, including potable reuse. This study takes an in-depth evaluation of a combination of membrane-based tertiary processes for its application in reuse of brewery wastewater, and is one of the few studies that evaluates long-term membrane performance at the pilot-scale. Two different advanced tertiary treatment trains were tested with secondary wastewater from a brewery wastewater treatment plant (A) ultrafiltration (UF) and reverse osmosis (RO), and (B) ozonation, coagulation, microfiltration with ceramic membranes (MF) and RO. Three specific criteria were used for membrane comparison: 1) pilot plant optimisation to identify ideal operating conditions, 2) Clean-In-Place (CIP) procedures to restore permeability, and 3) final water quality obtained. Both UF and Micro-Filtration membranes were operated at increasing fluxes, filtration intervals and alternating phases of backwash (BW) and chemically enhanced backwash (CEB) to control fouling. Operation of polymeric UF membranes was optimized at a flux of 25–30 LMH with 15–20 min of filtration time to obtain longer production periods and avoid frequent CIP membrane cleaning procedures. Combination of ozone and coagulation with ceramic MF membranes resulted in high flux values up to 120 LMH with CEB:BW ratios of 1:4 to 1:10. Coagulation doses of 3–6 ppm were required to deal with the high concentrations of polyphenols (coagulation inhibitors) in the feed, but higher concentrations led to increasing fouling resistance of the MF membrane. Varying the ozone concentration stepwise from 0 to 25 mg/L had no noticeable effect on coagulation. The most effective cleaning strategy was found to be a combination of 2000 mg/L NaOCl followed by 5% HCl which enabled to recover permeability up to 400 LMH·bar −1 . Both polymeric UF and ceramic MF membranes produced effluents that fulfil the limits of the national regulatory framework for reuse in industrial services (RD 1620/2007). Coupling to the RO units in both tertiary trains led to further water polishing and an improved treated water quality.

Gravity-driven ultrafiltration and nanofiltration recycled membranes for tertiary treatment of urban wastewater

DYEING WASTEWATER TREATMENT AND REUTILIZATION THROUGH ULTRAFILTRATION AND NANOFILTRATION INTEGRATED MEMBRANE PROCESSES

Membrane filtration technologies applied to municipal secondary effluents for potential reuse

Membrane-Based Processes to Obtain High-Quality Water From Brewery Wastewater

Ultrafiltration Membranes System: A Proposal to Remove Emerging Pollutants in Urban Wastewater

The Removal of Selected Inorganics from Municipal Membrane Bioreactor Wastewater Using UF/NF/RO Membranes for Water Reuse Application: A Pilot-Scale Study

Direct membrane filtration of municipal wastewater: Assessment of different fouling control strategies to enhance its energy, environmental and economic viability

Low-cost recycled end-of-life reverse osmosis membranes for water treatment at the point-of-use

Evaluation of the nanofiltration of brines from seawater desalination plants as pre-treatment in a multimineral brine extraction process

Environmental and economic assessment of urban wastewater reclamation from ultrafiltration membrane-based tertiary treatment: Effect of seasonal dynamic

Performance evaluation of nanofiltration membranes for SWRO brine valorisation: Insights from a pilot plant under real conditions

Integrated Membrane Process for the Treatment and Reuse of Residual Table Olive Fermentation Brine and Anaerobically Digested Sludge Centrate

Membrane technology for water reuse in decentralised non-sewered sanitation systems: Comparison of pressure driven (Reverse Osmosis) and thermally driven processes (Membrane Distillation and Pervaporation)

The feasibility of nanofiltration membrane bioreactor (NF-MBR)+reverse osmosis (RO) process for water reclamation: Comparison with ultrafiltration membrane bioreactor (UF-MBR)+RO process.

Feasibility of Using an Innovative Pvdf Mf Membrane Prior to Ro for Reuse of A Secondary Municipal Effluent

Thin Film Composite Polyamide Reverse Osmosis Membrane Technology towards a Circular Economy

Reclamation of impacted urban phreatic water through nanofiltration technology: Insight on natural organic matter removal by fluorescence spectroscopy

ANALYSIS AND FEASIBILITY OF CHEMICAL PRODUCTS REDUCTION IN THE CLEAN IN PLACE OF ULTRAFILTRATION AS A PRE-TREATMENT TECHNOLOGY FOR REVERSE OSMOSIS DESALINATION

Ecological Risk Evaluation and Removal of Emerging Pollutants in Urban Wastewater by a Hollow Fiber Forward Osmosis Membrane

Ultrafiltration after primary settler to enhance organic carbon valorization: Energy, economic and environmental assessment