Abstract:The use of renewable energies and alternative fuels to replace fossil fuels is a goal for reducing greenhouse gas emissions. Biogas is a promising option to substitute natural gas, but adequate purification of the produced biogas is necessary (the CO2 content of raw biogas must be reduced). Membrane technologies have proven its technical viability to purify biogas until the defined requirements. Moreover, membranes based on biopolymers could reduce the environmental footprint of these purification processes. Nevertheless, due to the trade-off between purity and recovery, single-stage processes are not able to attain desired targets, so multiple stages are required to reach the desired high purities and recoveries. The aim of this study is to advance the use of biopolymer-based membranes for the separation of CO2/CH4 and evaluate the economic competitiveness of the designed multistage purification process. For this purpose, a chitosan composite membrane with organic (ionic liquid) and inorganic (titanosilicate) fillers in the selective layer was used to study the multistage configuration, considering CO2 and CH4 as both target products. The process configuration is based on three membrane units operating in series to enrich CO2 in the product stream from the permeate line, while the retentates are collected from each stage and mixed to obtain a CH4-rich stream in the retentate. The target objectives were purities and recoveries of ≥95% of CO2 in the permeate outlet and ≥97% of CH4 in the retentate outlet stream of the multistage process. The economic evaluation of the proposed three-stage separation process was performed for different process scales, from small installations to large plants (100–1000 N m3 h–1 feed flow rate basis), operated with two different pressure ratios (8 and 16). Total specific costs and contributions of the different cost terms to fixed and operating costs were estimated. Operating costs were the largest contributor to total costs in all of the scenarios studied. To highlight the total specific costs for the installations of 1000 N m3 h–1 capacity, the obtained total costs were 0.33 and 0.20 US $ N m3– for the 8 and 16 pressure ratio values, respectively. This latter cost was competitive when compared to the cost published in the literature. Moreover, a sensitivity analysis was performed to evaluate the effects of increased specific costs of materials (membrane cost) and energy (electricity cost) on the total specific costs of the three-stage separation process.

Ultrafiltration after primary settler to enhance organic carbon valorization: Energy, economic and environmental assessment

Environmental and economic assessment of urban wastewater reclamation from ultrafiltration membrane-based tertiary treatment: Effect of seasonal dynamic

Direct membrane filtration of municipal wastewater: Assessment of different fouling control strategies to enhance its energy, environmental and economic viability

Resources recovery from domestic wastewater by a combined process: anaerobic digestion and membrane photobioreactor

Anaerobic membrane bioreactor performance at different wastewater pre-concentration factors: An experimental and economic study

Technical and environmental evaluation of an integrated scheme for the co-treatment of wastewater and domestic organic waste in small communities

Integrated Membrane Process for the Treatment and Reuse of Residual Table Olive Fermentation Brine and Anaerobically Digested Sludge Centrate

Ultrafiltration Membranes System: A Proposal to Remove Emerging Pollutants in Urban Wastewater

Combined coagulation and membrane treatment for anaerobically digested manure centrate: Contaminant residuals and membrane fouling

Gravity-driven ultrafiltration and nanofiltration recycled membranes for tertiary treatment of urban wastewater

Techno-economic evaluation and comparison of PAC-MBR and ozonation-UV revamping for organic micro-pollutants removal from urban reclaimed wastewater

Improved low-carbon-consuming fouling control in long-term membrane-based sewage pre-concentration: The role of enhanced coagulation process and air backflushing in sustainable sewage treatment

Coupling AnMBR, Primary Settling and Anaerobic Digestion to Improve Carbon Fate When Treating Sulfate-Rich Wastewater

Economic and environmental sustainability of an AnMBR treating urban wastewater and organic fraction of municipal solid waste

A Semi-Industrial Anmbr Plant for Urban Wastewater Treatment at Ambient Temperature: Analysis of the Filtration Process, Energy Balance and Quantification of GHG Emissions

Membrane aerated biological reactors (MABRs) to enhance the biological treatment process at a WWTP

Analysis of the Techno-Economic Competitiveness of a Three-Stage Membrane Separation Process for Biogas Upgrading Using a Biopolymer-Based Mixed-Matrix Membrane

Investigation of the agricultural reuse potential of urban wastewater and other resources derived by using membrane bioreactor technology within the circular economy framework

Life cycle assessment and economic analysis of anaerobic membrane bioreactor whole-plant configurations for resource recovery from domestic wastewater

Techno-economic Feasibility of “Membrane-Based Pre-Concentration + Post-Treatment” Systems for Municipal Wastewater Treatment and Resource Recovery