Abstract:The present study was aimed at the development of a strategy for removing and degrading perfluorohexanoic acid (PFHxA) from industrial process waters at concentrations in the range 60-200 mg L-1. The treatment train consisted of nanofiltration (NF) separation followed by electrochemical degradation of the NF concentrate. Using a laboratory-scale system and working in the total recirculation mode, the DowFilm NF270 membrane provided PFHxA rejections that varied in the range 96.6-99.4% as the operating pressure was increased from 2.5 to 20 bar. The NF operation in concentration mode enabled a volume reduction factor of 5 and increased the PFHxA concentration in the retentate to 870 mg L-1. Results showed that the increase in PFHxA concentration and the presence of calcium sulfate salts did not induce irreversible membrane fouling. The NF retentate was treated in a commercial undivided electrochemical cell provided with two parallel flow-by compartments separated by bipolar boron doped diamond (BDD) electrode, BDD counter anode, and counter cathode. Current densities ranging from 20 to 100 A m-2 were examined. The electrochemical degradation rate of PFHxA reached 98% and was accompanied by its efficient mineralization, as the reduction of total organic carbon was higher than 95%. Energy consumption, which was 15.2 kWh m-3 of treated NF concentrate, was minimized by selecting operation at 50 A m-2. While most of the previous research on the treatment of perfluoroalkyl substances (PFASs) focused on the removal of perfluorooctanoic acid (PFOA) and perfluorooctane sulfonate (PFOS), these compounds have been phased out by chemical manufacturers. Our findings are relevant for the treatment of PFHxA, which appears to be one of the present alternatives to long-chain PFASs thanks to its lower bioaccumulative potential than PFOA and PFOS. However, PFHxA also behaves as a persistent pollutant. Moreover, our results highlight the potential of combining membrane separation and electrochemical oxidation for the efficient treatment of PFAS-impacted waters.

Reclamation of impacted urban phreatic water through nanofiltration technology: Insight on natural organic matter removal by fluorescence spectroscopy

Desalting and Recovering Naphthalenesulfonic Acid from Wastewater with Concentrated Bivalent Salt by Nanofiltration Process

Phosphorus recovery from waters using nanofiltration

Removing emerging perfluoroalkyl ether acids and fluorotelomer sulfonates from water by nanofiltration membranes: Insights into performance and underlying mechanisms

Removal of Micropollutants in Water Reclamation by Membrane Filtration: Impact of Pretreatments and Adsorption

Membrane filtration technologies applied to municipal secondary effluents for potential reuse

A review of advances in EDCs and PhACs removal by nanofiltration: Mechanisms, impact factors and the influence of organic matter

Membrane fouling control and contaminant removal during direct nanofiltration of surface water

Removal of natural organic matter from surface water sources by nanofiltration and surface engineering membranes for fouling mitigation - A review

Application of high-dose UV irradiation as nanofiltration pretreatment for drinking water production: Organic fouling mitigation and micropollutant removal

Efficient treatment of perfluorohexanoic acid by nanofiltration followed by electrochemical degradation of the NF concentrate

Prediction of Flux and Rejection Coefficients in the Removal of Emerging Pollutants Using a Nanofiltration Membrane

Application and environmental impact of loose nanofiltration in surface water treatment

Treatment of highly iron-contaminated brackish groundwater by MF, UF, and NF membranes for potable water resource production: influence of operating parameters, comparative study, membrane fouling, and machine learning modeling

Plasma-aerosol-assisted interface engineering of nanofiltration membranes to improve removal of organic pollutants from water

The role of medium molecular weight organics on reducing disinfection by-products and fouling prevention in nanofiltration

Study on groundwater recharge with reclaimed water treated by soil-nanofiltration system

Evaluation of the nanofiltration of brines from seawater desalination plants as pre-treatment in a multimineral brine extraction process

Rejection of emerging organic micropollutants in nanofiltration-reverse osmosis membrane applications

Purifying surface water contaminated with azo dyes using nanofiltration: Interactions between dyes and dissolved organic matter

Unraveling flux behavior of superhydrophilic loose nanofiltration membranes during textile wastewater treatment