Abstract:In the textile industry, high salinity waste streams are a challenge urging for the recovery and purification of dyes and salts (e.g., NaCl), requiring a treatment going beyond the classical filtration by e.g., reverse osmosis to produce pure water. In this work, two commercial loose nanofiltration (NF) membranes (Sepro NF 6 and NF 2A, Ultura) are proposed to fractionate dye/salt aqueous mixtures. It was observed that both NF membranes have a salt rejection <33.3% in solutions with 0.1–40.0g L−1 of NaCl at 6bar. Furthermore, both membranes have >99.6% retention of direct dyes (direct red 80, direct red 23, and congo red), even though 40.0g L−1 NaCl is present, indicating salt addition has no obvious impact on the dye retention. The combination of a low salt rejection and a high dye rejection indicates the feasibility for the reuse of salt from fractionation in forward osmosis and bipolar membrane electrodialysis. Application of diafiltration for an aqueous mixture containing direct red 80 (1000ppm) and NaCl (~20g L−1) by both membranes demonstrates that above 95% of NaCl is removed from aqueous mixture, and <0.9g L−1 NaCl remains after the addition of pure water with a volume factor of 4.0 in the feed solution. At the premise of excellent diafiltration performance, concentration as the post-treatment for dye recovery expectedly indicates direct red 80 is concentrated by a factor of 4.0 for both membranes while keeping the salt concentration with a very slight increase. Over 99.9% dye retention in both diafiltration and concentration procedures yields a very high recovery since <0.045% of dye is permeated. These results indicate that loose nanofiltration membranes have potential for dye/salt fractionation.

Unraveling flux behavior of superhydrophilic loose nanofiltration membranes during textile wastewater treatment

Tuning of Nanofiltration Membrane by Multifunctionalized Nanovesicles to Enable an Ultrahigh Dye/salt Separation at High Salinity

Tight ultrafiltration membranes for enhanced separation of dyes and Na2SO4 during textile wastewater treatment

DYEING WASTEWATER TREATMENT AND REUTILIZATION THROUGH ULTRAFILTRATION AND NANOFILTRATION INTEGRATED MEMBRANE PROCESSES

Nanofiltration hollow fiber membranes for textile wastewater treatment: Lab-scale and pilot-scale studies

Scalable dual-layer PVDF loose nanofiltration hollow fiber membranes for treating textile wastewater

Loose Nanofiltration-Based Electrodialysis for Highly Efficient Textile Wastewater Treatment

A Comprehensive Physico-Chemical Characterization of Superhydrophilic Loose Nanofiltration Membranes

Facile and Novel Fabrication of High-Performance Loose Nanofiltration Membranes for Textile Wastewater Recovery

Fractionation of Direct Dyes and Salts in Aqueous Solution Using Loose Nanofiltration Membranes

Loose nanofiltration membrane with highly-branched SPEI/PEI assembly for dye/salt textile wastewater treatment

Separation of textile wastewater using a highly permeable resveratrol-based loose nanofiltration membrane with excellent anti-fouling performance

Fabrication of Loose Nanofiltration Membrane with Laponite Nanosheets Incorporated into Polyamide Layer for Effective Dye/divalent Salt Separation

Fabrication of highly permeable PVDF loose nanofiltration composite membranes for the effective separation of dye/salt mixtures

Effect of Dye Aggregation and Salting-out on Membrane Fouling and Control Measures During Nanofiltration of Saline Dye Wastewater

Tailoring nanofiltration membranes for effective removing dye intermediates in complex dye-wastewater

High-Performance Polyacrylic Acid-Grafted PVDF Nanofiltration Membrane with Good Antifouling Property for the Textile Industry

Development of antifouling nanofiltration membrane with zwitterionic functionalized monomer for efficient dye/salt selective separation

Designing durable self-cleaning nanofiltration membranes via sol-gel assisted interfacial polymerization for textile wastewater treatment

A Loose Nanofiltration Membrane Prepared by Interfacial Radical Polymerization for Dye/salt Separation

Conventional Ultrafiltration As Effective Strategy for Dye/Salt Fractionation in Textile Wastewater Treatment.