Abstract:Interfacial shear stress has an important influence on the vapor downward condensation heat transfer in a smaller diameter condenser tube. At the present work, a volume of fluid (VOF) method based on the vapor-liquid interfacial capturing technique was used to numerically analyze the effects of interfacial shear stress on local condensation heat transfer coefficients (HTC) during the vapor downflow condensation. Because vapor condenses on the vapor-liquid interface, the condensation mass and energy source items were introduced into the volume fraction and energy governing equations of the VOF model. In addition, the condenser tube wall temperature was acquired by a coupling calculation of cooling water forced convection heat transfer. The parameters were obtained, including velocity, interfacial shear stress and local condensation HTC. The computations show that interfacial stress shear degrades along the tube length, obviously improving the condensation heat transfer at the condenser tube front. At the condenser tube rear, the vapor-liquid interfacial shear stress decreases, having a drag force to condensate. Therefore, the liquid-film gravity plays an important role in local condensation HTC at the condenser tube rear. Local condensation HTC obtained by the VOF method is compared with the Nusselt analytic solution. At the condenser tube front, the vapor-liquid interfacial shear stress is higher and has the same direction as condensate velocity, which enhances the condensation heat transfer by reducing the liquid film thickness. So local condensation HTC obtained by the VOF method is higher than the Nusselt analytic solution. However, at the condenser tube rear, the computing result is almost equal to the Nusselt analytic solution as a result of both lower interfacial shear stress and increasing the liquid film thickness. Furthermore, a comparison of local condensation HTC acquired by the VOF method to the experimental data of Goodykoontz et al. was performed, good agreements were found for the condenser tube section from 0.2 m to 0.6 m, and their relative error is within ±35%. © All Rights Reserved.

Explorations of multi‐pass‐orifice header in the liquid‐separation condenser by using CFD simulation

Numerical simulation on the header-orifice structure-based liquid-vapor separator used in liquid-separation condenser

Numerical study of R134a liquid-vapor flow in a vertical header for phase separation with low inlet quality

Numerical Simulation of Multi-Pass Parallel Flow Condensers with Liquid-Vapor Separation

Prediction and Verification of the Thermodynamic Performance of Vapor–liquid Separation Condenser

Comparative Study of Heat Transfer Enhancement on Liquid-Vapor Separation Plate Condenser

Optimization of a microchannel condenser with separation circuitry

Optimized Liquid-Separated Thermodynamic States for Working Fluids of Organic Rankine Cycles with Liquid-Separated Condensation

An experimentally validated model for microchannel condensers with separation circuitry

Investigation on Interphase Mixing and Flow Condensation Process in a Vertical Channel

Experimental Study of Condensation Heat Transfer of R134a Inside the Micro-Fin Tubes at High Mass Flux

Thermo-economic Performance Evaluation of Emerging Liquid-Separated Condensation Method in Single-Pressure and Dual-Pressure Evaporation Organic Rankine Cycle Systems

Effect of Geometric Parameters of Liquid-Gas Separator Units on Phase Separation Performance

Inundation Correlation Research on the Simulation of Two-Phase Flow and Heat Transfer in a Condenser

CFD simulation of water vapour condensation in the presence of non-condensable gas in vertical cylindrical condensers

Analysis of interfacial shear stress effects on vapor downward condensation heat transfer

Passive Control of Gas–liquid Flow in a Separator Unit Using an Apertured Baffle in a Parallel-Flow Condenser

Experimental Investigation on Condensation Heat Transfer and Pressure Drop of High Saturation Temperature Organic Fluid in a Horizontal Smooth Tube

Numerical investigation of the thermal performance of a loop thermosyphon considering dynamic condensation mass transfer time relaxation parameter

Study of Two-Phase Flow Distribution in Microchannel Heat Exchanger Header - A Numerical Simulation

Numerical Study on R32 Flow Condensation in Horizontally Oriented Tubes with U-Bends