Abstract:An ultrathin surface layer with extraordinary molecular mobility has been discovered and intensively investigated on thin-film polymer materials for decades. However, because of the lack of suitable characterization techniques, it remains largely unexplored whether such a surface mobile layer also exists on individual polymeric nanospheres. Here, we propose a thermal-optical imaging technique to determine the glass transition (T-g) and rubber-fluid transition (T-f) temperatures of single isolated polystyrene nanospheres (PSNS) in a high-throughput and nonintrusive manner for the first time. Two distinct steps, corresponding to the glass transition and rubber-fluid transition, respectively, were clearly observed in the optical trace of single PSNS during temperature ramping. Because the transition temperature and size of the same individuals were both determined, single nanoparticle measurements revealed the reduced apparent T-f and increased T-g of single PSNS on the gold substrate with a decreasing radius from 130 to 70 nm. Further experiments revealed that the substrate effect played an important role in the increased T-g. More importantly, a gradual decrease in the optical signal was detected prior to the glass transition, which was consistent with a surface layer with enhanced molecular mobility. Quantitative analysis further revealed the thickness of this layer to be similar to 8 nm. This work not only uncovered the existence and thickness of a surface mobile layer in single isolated nanospheres but also demonstrated a general bottom-up strategy to investigate the structure-property relationship of polymeric nanomaterials by correlating the thermal property (T-g and T-f) and structural features (size) at single nanoparticle level.

Rubbery layer on polystyrene surface well below the glassy temperature

Rubbery State of Surface Polymers Enhanced by Body Glassy State

Physically-based Interpretation of Abnormal Stress Relaxation Response in Glassy Polymers

Intramolecular Dynamic Coupling Slows Surface Relaxation of Polymer Glasses

Microscale mobile surface double layer in a glassy polymer

Optical Imaging of the Molecular Mobility of Single Polystyrene Nanospheres

Rupturing of Polymer Films with Rubbing-Induced Surface Defects

Surface and Bulk Relaxation of Vapour-Deposited Polystyrene Glasses

Manifestation of sub-Rouse modes in flow at the surface of low molecular weight polystyrene

Dewetting of Polymer Films with Built-In Topographical Defects

Frictional behavior of solid polymers on a metal surface at processing conditions

Friction as a probe of surface properties of a polymer glass

Ultrathin Shell Layers Dramatically Influence Polymer Nanoparticle Surface Mobility

Effects of chain ends and densities on the glass transition of polymer thin films probed by linear and cyclic polystyrene

The Polymer Monolayer and the Probable Existence of Rubbery State in Two-dimensional Polymer Monolayer

Segmental dynamics of polystyrene near polymer–polymer interfaces

Viscosity and Surface-Promoted Slippage of Thin Polymer Films Supported by a Solid Substrate

Autophobicity and Layering Behavior of Thin Liquid-Crystalline Polymer Films

Interfacial Dynamics Governs the Mechanical Properties of Glassy Polymer Thin Films

WHAT ARE THE DIFFERENCES OF POLYMER SURFACE RELAXATION FROM THE BULK?

Static and dynamic behavior of poly(styrene-maleic anhydride) monolayer