Abstract:For thermal energy storage reactors with gas-solid bubbling fluidized bed, the bubbles have important effects on the heat and mass transfer capabilities as well as temperature homogeneity. Therefore, it is necessary to investigate the bubble dynamic behaviors, which is affected importantly by the particle size, for the design, and operation of bubbling fluidized bed reactors. In the present work, four particles with narrow size were sieved as the bed materials to study the effects of particle size on bubble dynamic behaviors at superficial gas velocity of 0.56 m·s −1 in a quasi-two-dimensional (quasi-2D) fluidized bed. The bubble dynamic behaviors, including bubble equivalent diameter, bubble size distribution, average bubble density, bubble aspect ratio, bubble hold-up, bed expansion ratio, bubble velocity, and bubble rising angle, at full bubbling fluidization were derived by digital image analysis (DIA) post-processing technique. The results shown that the bubble equivalent diameter increased with the increasing of particle size. For four particles, the bubble size distributions shown the similar distribution features, which indicated that the particle size had rare effects on it. Near the air distributor and freeboard, with increasing particle size, the average bubble density increased. The modes of bubble aspect ratio were all lower than 1, indicating that most of bubbles were vertically oblong ellipse. Additionally, the mode of the bubble aspect ratio tended to increase with the increasing of the particle size. Both time-averaged bed expansion ratio and bubble hold-up increased with increasing particle size. Bed fluctuation of smaller particles was more intense, but it was converse for the bubble hold-up. Inside the fluidized bed, two uniform "core-annular" flows were formed, and there was no evident difference in the radial distribution among four particles. Additionally, the particle size had little effects on the bubble rising velocity, which increased with increasing bubble equivalent diameter only, and proposed correlation with velocity coefficients of 1.09 was in line with the correlation coefficients in the literatures. Depending on the bubble rising angle, the bubble movement from the biased random movement to the main upward movement was dominant. Mastering the effects of particle size on bubble dynamic behaviors comprehensively is beneficial for the design, operation, and optimization of thermal energy storage reactors with gas-solid bubbling fluidized bed.

The motion mechanism and characteristic of bubble in a pseudo-2D tapered fluidized bed

Solid Concentration and Velocity Distributions in an Annulus Turbulent Fluidized Bed

Experimental and numerical investigation of solid behavior in a gas–solid turbulent fluidized bed

Numerical simulation of pressure fluctuation in gas-solids agitated fluidized bed

Hydrodynamic analysis of carbon nanotube in pilot-scale distributor-less tapered fluidized bed

Bubble Characterization in the Gas-Solid Fluidized Bed Using an Intrusive Acoustic Emission Sensor Array

Experimental Investigation of Bubble and Particle Motion Behaviors in A Gas-Solid Fluidized Bed with Side Wall Liquid Spray

CFD Simulation and Experiments of Dynamic Parameters in Gas–solid Fluidized Bed

Characterization of Flow Pattern of Cohesive Particles in Gas-Solid Fluidized Bed Via Axial Distribution of Particle Motions

Bubble Size “bimodal” Distribution Enhances Mixing and Mass Transfer in Slurry Bubbling Column Reactor

Research on Fluidization Performance of Different Tapered Fluidized Bed Reactors for Fluidizing Carbon Nanotubes

Design and Experimental Study of a Tapered Fluidized Bed Reactor without a distributor of Carbon Nanotubes

Bubble Dynamics and Particle Orientation in a Binary Fluidized Bed Containing Spherocylinders and Spheres

Bubble Dynamics Properties of B-particles in a Quasi-2D Gas-Solid Fluidized Bed: Computational Particle Fluid Dynamics Numerical Simulation and Post-Processed by Digital Image Analysis Technique

Effect of Cohesive Particle Addition on Bubbling Characteristics of Gas-Solid Fluidized Bed: Meso-scale Mechanism

Experimental study on bubble behavior in gas–liquid–solid three-phase circulating fluidized beds

Effects of particle size on bubble dynamic behaviors in a quasi-two-dimensional gas-solid fluidized bed

Effect of Bed Thickness on a Pseudo 2D Gas-Solid Fluidized Bed Turbulent Flow Structures and Dynamics

Fluidization characteristics, solids distributions and gas mixing of a carbon nanotube agglomerate fluidized bed

Hydrodynamics and Gas Mixing in A Carbon Nanotube Agglomerate Fluidized Bed

Tow-dimensional CFD simulation of bubbly flow in structured packings