Abstract:The flow condensation heat transfer coefficient of R134a inside two helical micro-fin tubes with outer diameter of 6.35 mm and helical angles of 18o and 28o respectively were experimentally studied at a high mass flux ranging from 500 to 1100 kg m−2 s−1. The condensation temperatures are 35°C, 40°C and 45°C, and the vapor qualities ranges from 0.95 to 1.00 at the inlet section and from 0.00 to 0.05 at the outlet section. Experimental results show that there are annular and intermittent flow regimes inside the tube under experimental conditions, the ratio of annular flow region to the total heat transfer region is about 70%. The liquid film flow changes from rotational flow to coexistence of rotational and horizontal flows when the vapor quality is 0.475±0.08, 0.486±0.06 and 0.521±0.05, respectively and the corresponding saturation temperature is 35°C, 40°C and 45°C. Based on the experimental data, the heat transfer coefficient increases with increasing mass flux and fin helical angle, and with decreasing saturation temperature and Reynolds number of cooling water. In addition, the heat transfer coefficient of annular flow is greater than that of intermittent flow, in other words, the heat transfer coefficient increases with increasing vapor quality. The heat transfer coefficient obtained at high mass flux was compared with the calculated data of some published correlations used at low mass flux. It was found that most correlations underestimate the experimental heat transfer coefficient inside the micro-fin tube, and these prediction deviation increases with increasing mass flux and fin helical angle. By introducing some dimensionless numbers as well as considering the flow mechanism of liquid film inside the tube, two heat transfer coefficient correlations were proposed based on the experimental data. The ratio of liquid film thickness to fin height was used to characterize whether the liquid film flow is rotational flow or coexistence of rotational and horizontal flows in the proposed correlation, which shows a better prediction accuracy with a mean deviation of less than 7.3%.

Condensation heat fluxes from mixed convection flows of steam and air mixtures on a vertical flat plate

Prediction Method of Condensation Heat Transfer from Steam-Air Mixture for CFD Application

Numerical Simulation of Wall Condensation from a Superheated Steam and Air Mixture in a Vertical Pipe

Numerical Analysis of Buoyancy-Driven Exchange Flow with Regard to an HTTR Air Ingress Accident

Numerical Investigation of Natural Convective Condensation with Noncondensable Gases in the Reactor Containment after Severe Accidents

Boundary layer measurements for validating CFD condensation model and analysis based on heat and mass transfer analogy in laminar flow condition

Identification and classification of the flow pattern of hydrogen-air-steam mixture gas under steam condensation

Numerical Investigation of Convective Condensation with the Presence of Non-Condensable Gases in A Vertical Tube

Numerical investigations on the component separation phenomenon and transport behavior of steam-air-hydrogen mixture induced by condensation

Experimental Study of Condensation Heat Transfer of R134a Inside the Micro-Fin Tubes at High Mass Flux

Analysis of wave influence on steam condensation with non-condensable gases using cfd

Direct numerical simulation of turbulent mixed convection in a vertical channel in a wall-normal magnetic field

Effect of Non-Condensation Gas on Heat Transfer of Direct Contact Condensation

Experiments on heat transfer of smooth and swirl tubes under one-sided heating conditions

Condensation heat and mass transfer of steam with non-condensable gases outside a horizontal tube under free convection

Three-Dimensional Numerical Analysis of Mixed Convective Heat Transfer in a Horizontal Square Channel with Heated and Cooled Side Walls.

Numerical Analysis of Mixed Convective Heat Transfer In a Square Channel with Uniform Wall Temperature.

Improvement of Condensation Model With the Presence of Non-Condensable Gas for Thermal-Hydraulic Analysis in Containment

A CFD Study of Wave Influence on Film Steam Condensation in the Presence of Non-Condensable Gas

CFD Modeling of Film Condensation from a Steam-Air Mixture in Vertical Channels

Effect of Reynolds Correlations on Heat Transfer Calculation of Film Condensation in Turbulent Flow