Abstract:This paper presents a numerical model to study the process of vapor condensation on surfaces characterized by film-wise condensation with the presence of Non-condensable gases (NCG). State variables in both the condensate film and the diffusion layer were solved separately and the condensation interface was used to couple the two solutions. The solution of the condensate film was obtained using well-established solutions of laminar film condensation of pure vapor. In contrast to other models surveyed, this work provides a inexpensive and accurate predictions of heat and mass transfer characteristics. We validated the work against two classical condensation problems. The model was first validated against empirical correlations and experimental work, resulting in a very good agreement. We then assessed the applicability of ignoring the condensate film effect, as performed in previous models, on the condensation processes by observing the thermal resistances of both the condensate film and diffusion layer. Results indicated that for the studied cases of NCG mass fractions above 20%, the condensate thermal resistance was at least an order of magnitude lower than that of the diffusion layer. However, the two thermal resistances seem to approach each other as NCG mass fraction becomes smaller. On another front, we observed that models that ignore the condensate film thermal resistance underestimate the interfacial temperature albeit accurately predicting the overall heat transfer rate. To simulate even lower NCG mass fractions, we validated our model to the classical analytical work of Sparrow and co-workers. Results showed a striking agreement between the two solutions at different NCG mass fractions (0.5%–10%) and subcooling degrees (5∘F–40∘F). Finally, we found a good agreement between results of our model and the heat/mass transfer analogy. The heat/mass transfer analogy is a semi-empirical method therefore, is limited to the existing correlations and their uncertainties. On the other hand, our model does not use any empiricism and relies on the available solutions of laminar condensate film of pure vapor in predicting the liquid side heat transfer coefficient.

A CFD Study of Wave Influence on Film Steam Condensation in the Presence of Non-Condensable Gas

Analysis of wave influence on steam condensation with non-condensable gases using cfd

Numerical study on the condensation characteristics of vapor with non-condensable gas on inclined walls inside containment

CFD Modeling of Film Condensation from a Steam-Air Mixture in Vertical Channels

Improvement of Condensation Model With the Presence of Non-Condensable Gas for Thermal-Hydraulic Analysis in Containment

CFD simulation of water vapour condensation in the presence of non-condensable gas in vertical cylindrical condensers

Numerical Investigation of Natural Convective Condensation with Noncondensable Gases in the Reactor Containment after Severe Accidents

Numerical Investigation of Convective Condensation with the Presence of Non-Condensable Gases in A Vertical Tube

Numerical simulation on the effect of non-condensable gas on direct contact condensation of steam jet in a narrow pipe

Analysis Of Effects Of Buoyancy Force On Steam Condensation With Non-Condensable Gases In A Rectangular Channel

Effects of Liquid Film Waviness, Suction, and Fog Formation on Condensation in the Presence of Noncondensable Gases

Approximate Equations for Film Condensation in the Presence of Non-Condensable Gases

Improved CFD simulation of water hammer caused by condensation with an enhanced phase change model

Numerical simulation study on heat transfer characteristics of steam condensation in the presence of multi-component non-condensable gas outside the tube bundle

Effect of Non-Condensation Gas on Heat Transfer of Direct Contact Condensation

Assessment of steam condensation model with the presence of non-condensable gas in a vertical tube using RELAP5 Mod 3.2 code and MIT exp. Data

Numerical investigation on submerged steam jet condensation in subcooled water flow in a restricted channel with the presence of non-condensable gas

Numerical investigations on the component separation phenomenon and transport behavior of steam-air-hydrogen mixture induced by condensation

Model development and simulation on dropwise condensation by coupling absorption theory in the presence of non-condensable gas (NCG)

Characteristic Analysis of Fluctuating Liquid Film Flow Behavior and Heat Transfer in Nitrogen Condensation

Numerical modeling of vapor condensation over a wide range of non-condensable gas concentrations