Abstract:In the context of Oxy-fuel combustion, there is a strong industrial interest in highly fuel-rich flames, characterized by an equivalence ratio (Φ) exceeding 2.5, for the production of H 2 -CO-rich synthesis gas. The validation of existing chemical reaction mechanisms for this specific regime pose a significant challenge due to the scarcity of experimental data for this particular range of equivalence ratio. The scope of this study was therefore the determination of the laminar burning velocity s L of ultra-rich CH 4 -O 2 flames under varying conditions, such as high equivalence ratios and preheating temperatures using the heat flux burner method. The laminar burning velocity was determined for equivalence ratio within the range of 2.3 < Φ < 3.6 and preheating temperature ranging from 300 K to 455 K. Additionally, the impact of the of reducing the oxygen content in the oxidizer on s L was investigated by argon addition in molar percentages ranging from 40 % to 100 %. The results of our study reveal laminar burning velocities ranging from 5 cm/s to 45 cm/s for pure oxy-fuel CH 4 flames. Preheating is shown to increase s L and this effect can be represented by a power law correlation s L = s L,0 (T/T 0 ) α with α = 1.53. Furthermore, the dilution of the oxidizer with argon leads to a significant decrease in s L of approximately 50 % compared to pure oxy-fuel flames. It is worth noting that detailed reaction mechanisms in combination with molecular transport data are typically not validated within the selected equivalence ratio range. To assess the performance of such reaction schemes in predicting laminar burning velocity under the specified selected conditions, we evaluated 13 different reaction mechanisms sourced from the literature. We compared the laminar burning velocities obtained through calculations of laminar premixed 1D flames and, additionally compared these with experimental data. A sensitivity analysis of the laminar burning velocity were carried out for selected mechanisms. Among the mechanisms, the CalTech2.3 mechanism exhibited the most consistent and accurate performance, particularly at high equivalence ratios.

The impact of equivalence ratio on the fire characteristics of Kerosene/air flame produced by NexGen burner for aeronautic application

Observation of Flame Propagation in a Heavy-Duty Natural-Gas Lean Burn Spark-Ignition Engine

Experimental investigations of the fire behavior of composites impacted by kerosene/air turbulent flame

Experimental study on the cavitation phenomenon effect on the efficiency of a turbulent premixed flame kerosene/air

A Comparison Between Direct Numerical Simulation and Experiment of the Turbulent Burning Velocity-Related Statistics in a Turbulent Methane-Air Premixed Jet Flame at High Karlovitz Number

Effects of Reactant Injection Conditions on Diffusion Combustion of Natural Gas in a Laboratory-scale Combustor

Experiment Study on Major and Intermediate Species of Ethanol/N-Heptane Premixed Flames

Numerical Study of Fluid Flows and Heat Transfer of Aviation Kerosene with Consideration of Fuel Pyrolysis and Surface Coking at Supercritical Pressures

Experimental Investigation of the Flame Front Propagation Characteristic During Light-round Ignition in an Annular Combustor

Laminar Burning Speed of Aviation Kerosene at Low Pressures

Experiment and Numerical Investigation on Counterflow Twin-flame of Isooctane/Air

Experimental investigation for temperature and emissivity by flame emission spectrum in a cavity of rocket based combined cycle combustor chamber

Measurements of the Critical Initiation Radius and Unsteady Propagation of N-Decane/air Premixed Flames

Comparison of the flame dynamics of a premixed dual fuel burner for kerosene and natural gas

An experimental study on aviation kerosene pool fire flame and thermal radiation

Flame investigations of a laboratory-scale CECOST swirl burner at atmospheric pressure conditions

Study on the Flame Transition Characteristics of a Gas Turbine Combustor

Experimental and numerical investigations of the laminar burning velocities of premixed fuel-rich methane oxy-fuel and oxygen-enhanced flames

Experimental Study on Fire Behaviors of Kerosene/Additive Blends

Experimental investigation on flame spread over jet fuel with influence of external heat radiation

An experimental and computational study of the burning rates of ultra-lean to moderately-rich H2/O2/N2 laminar flames with pressure variations