Abstract:Gas explosion in connected vessels usually leads to high pressure and high rate of pressure increase which the vessels and pipes can not tolerate. Severe human casualties and property losses may occur due to the variation characteristics of gas explosion pressure in connected vessels. To determine gas explosion strength, an experimental testing system for methane and air mixture explosion in a single vessel, in a single vessel connected a pipe and in connected vessels has been set up. The experiment apparatus consisted of two spherical vessels of 350 mm and 600 mm in diameter, three connecting pipes of 89 mm in diameter and 6 m in length. First, the results of gas explosion pressure in a single vessel and connected vessels were compared and analyzed. And then the development of gas explosion, its changing characteristics and relevant influencing factors were analyzed. When gas explosion occurs in a single vessel, the maximum explosion pressure and pressure growth rate with ignition at the center of a spherical vessel are higher than those with ignition on the inner-wall of the vessel. In conclusion, besides ignition source on the inner wall, the ignition source at the center of the vessels must be avoided to reduce the damage level. When the gas mixture is ignited in the large vessel, the maximum explosion pressure and explosion pressure rising rate in the small vessel raise. And the maximum explosion pressure and pressure rising rate in connected vessels are higher than those in the single containment vessel. So whenever possible, some isolation techniques, such as fast-acting valves, rotary valves, etc., might be applied to reduce explosion strength in the integrated system. However, when the gas mixture is ignited in the small vessel, the maximum explosion pressures in the large vessel and in the small vessel both decrease. Moreover, the explosion pressure is lower than that in the single vessel. When gas explosion happens in a single vessel connected to a pipe, the maximum explosion pressure occurs at the end of the pipe if the gas mixture is ignited in the spherical vessel. Therefore, installing a pipe into the system can reduce the maximum explosion pressure, but it also causes the explosion pressure growth rate to increase. (C) 2013 Elsevier Ltd. All rights reserved.

Research on Gas Explosion Pressure and Flame Propagation Characteristics in Turning Pipelines

Experimental study on characteristics of flame propagation and pressure development evolution during methane-air explosion in different pipeline structures

Visualization Study of Methane Deflagration Characteristics in Variable Diameter Pipelines Based on Schlieren Technique

Experimental Investigation Into Premixed Gases Explosion in Spherical Shape Vessel Added Pipes

Experimental Investigation And Numerical Simulation Of Gas Explosion In Linked Vessels

Effect Analysis of the Venting Direction on Explosion Pressure in LPG Pipelines

Experimental Investigation of Gas Explosion in Single Vessel and Connected Vessels

Study on effect of transverse concentration gradients in pipeline on methane explosion characteristics

Evolution characteristics of deflagration wave system and flame acceleration effect of combustible gas in variable-caliber pipelines

Experimental and numerical study of gas explosion from semi-submersible platform

Process Of Natural Gas Explosion In Linked Vessels With Three Structures Obtained Using Numerical Simulation

Research on overpressure hazards and flame propagation behaviors of CH4/air mixture explosions in a vessel-duct connected device

Study on Ground Vibration Mode of Physical Explosion of High Pressure Natural Gas Pipeline

Experimental Investigation of Gas Explosion Characteristic in Linked Vessels

Experimental and numerical study on natural gas explosion evolution in open space under different initial conditions

Study of explosion relief mechanisms in lateral explosion relief conduits of gas pipelines

Risk Assessment of Liquefied Petroleum Gas Explosion in a Limited Space

CFD Simulation on Gas Explosion Field in Linked Vessels

Experimental study on gas explosion and venting process in interconnected vessels

Numerical Analysis of Gas Explosion Process in Linked Vessels

Numerical study on the impact distance of a jet fire following the rupture of a natural gas pipeline