Abstract:The carbon dioxide (CO2) trans-critical cycle is widely used in refrigerating systems, air conditioning, and heat pumps. Heat transfer behaviors at subcritical and supercritical pressures play essential roles in trans-critical thermohydraulic systems. In past decades, boiling heat transfer at subcritical pressure and 'single-phase' convective heat transfer at supercritical pressure have been broadly discussed; however, evaluation of the heat transfer difference of CO2 between supercritical and subcritical pressures remains lacking. In this study, experimental investigations are conducted to explore the heat transfer characteristics of the vertical flow of CO2 in a wide pressure range (6.2 MPa-8.0 MPa) within a circular tube (inner diameter = 5 mm). The range of operating conditions includes a mass flux (G) between 0 and 190 kg/m(2) s and a heat flux (q) of up to 105 kW/m(2). Parametric effects (e.g., heat flux, inlet temperature, and mass flux) within these experimental conditions are also analyzed. Measurement results show that the inner-wall temperature at subcritical pressure is higher than that at supercritical pressure when a boiling crisis occurs. Closer to the critical pressure, a boiling crisis occurs more easily at lower heat fluxes, but the corresponding temperature peak declines. Higher temperatures are measured farther from critical pressure, indicating that overheating induced by boiling heat transfer at subcritical pressure is far more significant than that governed by the deterioration of convective heat transfer at supercritical pressure. Additionally, a qualitative analysis of physical mechanisms governing observed heat transfer differences is performed, confirming variations in fluid thermophysical properties and a bubble-like flow pattern. (C) 2020 Elsevier Ltd. All rights reserved.

Experimental Investigation of the Characteristics of Supercritical CO2 during the Venting Process

Experimental and Numerical Investigation on the Dynamic Characteristics of a Lab-Scale Transcritical CO2 Loop

A Potentially Non-Contact Monitor Method for CO2 at the Pseudo-Critical Region Using Infrared Spectrometer

Investigation on crack propagation and reasonable wall thickness of supercritical CO 2 pipeline

The leakage behavior of supercritical CO 2 flow in an experimental pipeline system

Experimental Comparison of the Heat Transfer of Carbon Dioxide under Subcritical and Supercritical Pressures

An Experimental Investigation of Supercritical CO2 Accidental Release from a Pressurized Pipeline

Analysis of Internal Corrosion of Supercritical CO2 Pipeline

Simulation study on near-field structure and flow characteristics of high-pressure CO<sub>2</sub> released from the pipeline

Safety Control on the Chocking Process of Supercritical Carbon Dioxide Pipeline

Experimental Investigation of Convection Heat Transfer of CO2 at Super-Critical Pressures in Vertical Mini-Tubes and in Porous Media

The Flow and Heat Transfer Characteristics of Supercritical CO2 Leakage from a Pipeline

Heat Transfer Characteristics of CO2 in a Horizontal Tube under Subcritical and Supercritical Pressures

Experimental study on convection heat transfer of supercritical CO2 in small upward channels

Simulation of boost path and phase control method in supercritical CO 2 pipeline commissioning process

Numerical Simulation on the Flow and Heat Transfer of Supercritical CO2 in Sudden Expansion Pipe under Cooling Condition

Numerical Investigation of Different Heat Transfer Behaviors of Supercritical CO2 in a Large Vertical Tube

Experimental and Numerical Investigation of Convective Heat Transfer of Supercritical Carbon Dioxide at Low Mass Fluxes

Classification and Characteristics of Supercritical Carbon Dioxide Leakage from a Vessel

Investigation of Dynamic Phase Changes in High-Pressure Pipelines During Flexible CO2 Transport

Numerical Investigation of the Leakage Flow from a Pressurized CO2 Pipeline