Abstract:Glycerol carbonate (GC) was synthesized by transesterification of glycerol with dimethyl carbonate (DMC) using calcium oxide (CaO) derived from eggshell as a catalyst. The best results of 96% glycerol conversion and 94% GC yield were achieved under the following reaction conditions: 0.08 mole ratio of CaO to glycerol, 1:2.5 mole ratio of glycerol to DMC, 60°C reaction temperature, and 3 hours reaction time. As expected, CaO showed deteriorated catalytic performance when recycling as observed by a rapid decrease in GC yield. This research showed that the active CaO phase first was converted to calcium methoxide (Ca[OCH3]2) and calcium diglyceroxide (Ca[C3H7O3]2) and finally to carbonate phase (CaCO3) which can be confirmed by XRD patterns. According to the phase transformation, the basicity decreased from 0.482 mmol/g to 0.023 mmol/g, and basic strength altered from strong basic strength (15.0 < H_ < 18.4) to weak basic strength (7.2 < H_ < 9.8), resulting in the lower catalytic activity of the consecutive runs. Despite the fact that the GC selectivity was almost 100%, the reaction products (methanol and GC) were not obtained in their stoichiometric ratio and their extents corresponded with that of the catalyst phase transformation to CaCO3. The mechanism of CaO catalyzed transesterification based on the condensation reaction of glycerol and catalyst was proposed, and in situ formation of water-derivative species was hypothesized as a cause of CaO transformation. CaO could react with DMC and water, generating methanol and CaCO3. This enabled unconventional monitoring of catalyst deactivation by checking if the mole ratio of methanol to GC was higher than 2:1 of its reaction stoichiometric ratio. It was also demonstrated that calcination of post-run catalyst at 900°C to CaO exhibited almost constant catalytic activity, and the mole ratio of methanol to GC was constant at its reaction stoichiometry (2:1) for at least 4 times use.

Experimental and Quantum Chemical Calculations on the High-Efficiency Transesterification of Dimethyl Carbonate with Alcohol Catalyzed by Calcium Oxide

Study on Catalytic Performance and Kinetics of High Efficiency CeO2 Catalyst Prepared by Freeze Drying for the Synthesis of Dimethyl Carbonate from CO2 and Methanol

Efficient Synthesis of Dimethyl Carbonate via Transesterification of Ethylene Carbonate Catalyzed by CN-SiAlO Composites

Transesterification of Glycerol with Dimethyl Carbonate over Calcined Ca-Al Hydrocalumite

Dimethyl carbonate synthesis over solid base catalysts derived from Ca–Al layered double hydroxides

Advances in the Catalysts for Synthesis of Dimethyl Carbonate (DMC) Via Liquid-Phase Oxidative Carbonylation of Methanol

Hydroxyl-functionalized Ionic Liquid for Activation and Conversion of CO2 and Methanol into Dimethyl Carbonate

Highly Dispersed CrOx Nanoparticle-Modified NaZSM-5 for Dehydration of Methanol to Dimethyl Ether

Mechanism of CaO catalyst deactivation with unconventional monitoring method for glycerol carbonate production via transesterification of glycerol with dimethyl carbonate

Efficient Synthesis of Dimethyl Carbonate Via Transesterification of Ethylene Carbonate over A New Mesoporous Ceria Catalyst

Superior silicon-free Cu catalyst for dimethyl oxalate hydrogenation: Exploring interaction between Cu and pyridinic-N-rich ultrathin carbon

Ionic Liquid Immobilized on Mesocellular Silica Foam As an Efficient Heterogeneous Catalyst for the Synthesis of Dimethyl Carbonate Via Transesterification

Tuning the cross-linked structure of basic poly(ionic liquid) to develop an efficient catalyst for the conversion of EC to DMC

KF/MgO used as the catalyst for transesterification of dimethyl carbonate with isosorbide to dicarboxymethyl isosorbide

Mg–Al Mixed Oxide Derived from Hydrotalcites Prepared Using the Solvent-Free Method: A Stable Acid–Base Bifunctional Catalyst for Continuous-Flow Transesterification of Dimethyl Carbonate and Ethanol

Study of Preparing Conditions of Methanol Liquid Oxidative Carbonylation to Dimethyl Carbonate

Catalytic materials for direct synthesis of dimethyl carbonate (DMC) from CO2

The role of Ce doping on the activity of La2O2CO3 nanosheets catalysts in synthesis of dimethyl carbonate from propylene carbonate and methanol

Boosting the catalytic activity via acid-base synergistic effect for CO2 and methanol direct to dimethyl carbonate

K‐doped CuO/ZnO with dual active centers of synergism for highly efficient dimethyl carbonate synthesis

Mesostructured Graphitic Carbon Nitride As A New Base Catalyst for the Efficient Synthesis of Dimethyl Carbonate by Transesterification