Abstract:Glycerol carbonate (GC) was synthesized by transesterification of glycerol with dimethyl carbonate (DMC) using calcium oxide (CaO) derived from eggshell as a catalyst. The best results of 96% glycerol conversion and 94% GC yield were achieved under the following reaction conditions: 0.08 mole ratio of CaO to glycerol, 1:2.5 mole ratio of glycerol to DMC, 60°C reaction temperature, and 3 hours reaction time. As expected, CaO showed deteriorated catalytic performance when recycling as observed by a rapid decrease in GC yield. This research showed that the active CaO phase first was converted to calcium methoxide (Ca[OCH3]2) and calcium diglyceroxide (Ca[C3H7O3]2) and finally to carbonate phase (CaCO3) which can be confirmed by XRD patterns. According to the phase transformation, the basicity decreased from 0.482 mmol/g to 0.023 mmol/g, and basic strength altered from strong basic strength (15.0 < H_ < 18.4) to weak basic strength (7.2 < H_ < 9.8), resulting in the lower catalytic activity of the consecutive runs. Despite the fact that the GC selectivity was almost 100%, the reaction products (methanol and GC) were not obtained in their stoichiometric ratio and their extents corresponded with that of the catalyst phase transformation to CaCO3. The mechanism of CaO catalyzed transesterification based on the condensation reaction of glycerol and catalyst was proposed, and in situ formation of water-derivative species was hypothesized as a cause of CaO transformation. CaO could react with DMC and water, generating methanol and CaCO3. This enabled unconventional monitoring of catalyst deactivation by checking if the mole ratio of methanol to GC was higher than 2:1 of its reaction stoichiometric ratio. It was also demonstrated that calcination of post-run catalyst at 900°C to CaO exhibited almost constant catalytic activity, and the mole ratio of methanol to GC was constant at its reaction stoichiometry (2:1) for at least 4 times use.

KF/MgO used as the catalyst for transesterification of dimethyl carbonate with isosorbide to dicarboxymethyl isosorbide

Synthesis of Dimethyl Carbonate via Transesterification of Ethylene Carbonate and Methanol over mesoporous KF‐loaded Mg‐Fe oxides

Synthesis of Dimethyl Carbonate from Methanol and Carbon Dioxide Using Potassium Methoxide As Catalyst under Mild Conditions

K‐doped CuO/ZnO with dual active centers of synergism for highly efficient dimethyl carbonate synthesis

Excess soluble alkalis to prepare highly efficient MgO with relative low surface oxygen content applied in DMC synthesis

Experimental and Quantum Chemical Calculations on the High-Efficiency Transesterification of Dimethyl Carbonate with Alcohol Catalyzed by Calcium Oxide

Transesterification of Glycerol to Glycerol Carbonate over Mg-Zr Composite Oxide Prepared by Hydrothermal Process

Ionic Liquid Immobilized on Mesocellular Silica Foam As an Efficient Heterogeneous Catalyst for the Synthesis of Dimethyl Carbonate Via Transesterification

Mechanism of CaO catalyst deactivation with unconventional monitoring method for glycerol carbonate production via transesterification of glycerol with dimethyl carbonate

Hydroxyl-functionalized Ionic Liquid for Activation and Conversion of CO2 and Methanol into Dimethyl Carbonate

Dimethyl carbonate synthesis over solid base catalysts derived from Ca–Al layered double hydroxides

Biodiesel Production Using MgO–CaO Catalysts via Transesterification of Soybean Oil: Effect of MgO Addition and Insights of Catalyst Deactivation

Mg–Al Mixed Oxide Derived from Hydrotalcites Prepared Using the Solvent-Free Method: A Stable Acid–Base Bifunctional Catalyst for Continuous-Flow Transesterification of Dimethyl Carbonate and Ethanol

Isosorbide bis(methyl carbonate) synthesis from isosorbide and dimethyl carbonate: the key role of dual basic-nucleophilic catalysts

Layered double hydroxide uniformly coated on mesoporous silica with tunable morphorlogies for catalytic transesterification of glycerol with dimethyl carbonate

Transesterification of Glycerol with Dimethyl Carbonate over Calcined Ca-Al Hydrocalumite

Synthesis and characterization of TiO2-V2O5-MCM-41 for catalyzing transesterification of dimethyl carbonate with phenol

Mesostructured Graphitic Carbon Nitride As A New Base Catalyst for the Efficient Synthesis of Dimethyl Carbonate by Transesterification

Selectively controlled synthesis of diethyl carbonate and methyl ethyl carbonate via transesterification of dimethyl carbonate over KATriz/Al¬2O3 catalyst

Boosting the catalytic activity via acid-base synergistic effect for CO2 and methanol direct to dimethyl carbonate

Natural Mg silicates with different structures and morphologies: Reaction with K to produce K2MgSiO4 catalyst for biodiesel production