Abstract:Glycerol carbonate (GC) was synthesized by transesterification of glycerol with dimethyl carbonate (DMC) using calcium oxide (CaO) derived from eggshell as a catalyst. The best results of 96% glycerol conversion and 94% GC yield were achieved under the following reaction conditions: 0.08 mole ratio of CaO to glycerol, 1:2.5 mole ratio of glycerol to DMC, 60°C reaction temperature, and 3 hours reaction time. As expected, CaO showed deteriorated catalytic performance when recycling as observed by a rapid decrease in GC yield. This research showed that the active CaO phase first was converted to calcium methoxide (Ca[OCH3]2) and calcium diglyceroxide (Ca[C3H7O3]2) and finally to carbonate phase (CaCO3) which can be confirmed by XRD patterns. According to the phase transformation, the basicity decreased from 0.482 mmol/g to 0.023 mmol/g, and basic strength altered from strong basic strength (15.0 < H_ < 18.4) to weak basic strength (7.2 < H_ < 9.8), resulting in the lower catalytic activity of the consecutive runs. Despite the fact that the GC selectivity was almost 100%, the reaction products (methanol and GC) were not obtained in their stoichiometric ratio and their extents corresponded with that of the catalyst phase transformation to CaCO3. The mechanism of CaO catalyzed transesterification based on the condensation reaction of glycerol and catalyst was proposed, and in situ formation of water-derivative species was hypothesized as a cause of CaO transformation. CaO could react with DMC and water, generating methanol and CaCO3. This enabled unconventional monitoring of catalyst deactivation by checking if the mole ratio of methanol to GC was higher than 2:1 of its reaction stoichiometric ratio. It was also demonstrated that calcination of post-run catalyst at 900°C to CaO exhibited almost constant catalytic activity, and the mole ratio of methanol to GC was constant at its reaction stoichiometry (2:1) for at least 4 times use.

Transesterification of Glycerol with Dimethyl Carbonate over Calcined Ca-Al Hydrocalumite

Transesterification of glycerol with dimethyl carbonate over Mg-Al hydrotalcites

Transesterification of Glycerol to Glycerol Carbonate over Mg-Zr Composite Oxide Prepared by Hydrothermal Process

Dimethyl carbonate synthesis over solid base catalysts derived from Ca–Al layered double hydroxides

Experimental and Quantum Chemical Calculations on the High-Efficiency Transesterification of Dimethyl Carbonate with Alcohol Catalyzed by Calcium Oxide

Mechanism of CaO catalyst deactivation with unconventional monitoring method for glycerol carbonate production via transesterification of glycerol with dimethyl carbonate

Transesterification of Glycerol with Dimethyl Carbonate to Glycerol Carbonate over Na–based Zeolites

Efficient synthesis of ethylene carbonate via transesterification of ethylene glycol with dimethyl carbonate over Mg3Al1−xCexO composite oxide

Glycerol Carbonate Production via Transesterification: The Effect of Support Porosity and Catalyst Basicity

The atom-efficient production of glycerol carbonate via transesterification between dimethyl carbonate and glycerol over fluorinated Al 2 O 3 -ZrO 2 solid solution catalysts with suitable acidic-basic property

LTA zeolites as catalysts for transesterification of glycerol with dimethyl carbonate

Hydrogenolysis of Glycerol over Cu-substituted Hydrocalumite Mediated Catalysts

Using waste crayfish shell derived catalyst to synthesize glycerol carbonate by transesterification reaction between glycerol and dimethyl carbonate

Comparative study of catalytic conversion of glycerol, a by-product of transesterification, to cyclic hydrocarbons using MCM-22, ZSM-5 and alumina

Valorization of Glycerol to Glycerol Carbonate and Glycidol by Different Dialkyl Carbonates Utilizing Tricalcium Aluminate Hexahydrate as Transesterification Catalyst

Transformation of CO2 with Glycerol to Glycerol Carbonate over ETS-10 Zeolite-Based Catalyst

Synthesis of Dimethyl Carbonate via Transesterification of Ethylene Carbonate and Methanol over mesoporous KF‐loaded Mg‐Fe oxides

Structural study of mixed metal oxide catalysts comprising Mg, Ca, and Al used for upgrading biodiesel byproduct glycerol to glycerol carbonate

A Novel Hybrid Iron-Calcium Catalyst/absorbent for Enhanced Hydrogen Production Via Catalytic Tar Reforming with In-Situ CO2 Capture

La‐Doped Mg‐Al Composite Oxides: Efficient Catalysts for the synthesis of Diethyl Carbonate via Transesterification of Ethylene Carbonate with Ethanol

Glycerol carbonate synthesis via transesterification of enriched glycerol and dimethyl carbonate using a Li-incorporated MCM-41 framework