Abstract:Fused silica crucibles are commonly used in the fabrication process of solar grade silicon ingots. These crucibles are manufactured from high purity natural quartz sand and as a consequence, their properties are influenced by the presence of water and hydroxyls in the raw quartz. In this work, diffuse reflectance IR, 1H magic angle spinning NMR, and Raman spectroscopy were used to investigate the influence of thermal treatment on water and hydroxyl groups in high purity natural quartz sand. Most of the water in dry sand is present in the form of closed inclusions within the quartz grains which were detected in Raman imaging studies, even after thermally treating the samples at 600 °C. Only after heating to 900 °C did this water completely vanish, most likely as a result of rupturing of the inclusions. However, newly formed OH groups, identified as isolated and hydrogen bound OH were observed as products of the reaction between water and quartz. Similarly, liquid water was observed in NMR spectra even after treatment at 600 °C while at temperatures >900 °C, only non-interacting silanol groups were present. The comparison of the temperature dependence of the IR and NMR spectra also yields insight into the assignment of the OH stretching mode region of the IR spectrum in this system. The intensity of water related bands decreases while the intensity of OH bands first increases and then decreases with increasing temperature. The band intensity of Al-rich defects as well as the characteristic feature at 3200 cm-1 does not follow the temperature dependence of typical water peaks. It is also shown that leaching the quartz sand in HF solution helps to remove water from inclusions, likely by forming pathways for fluid flow inside the quartz grains. Milling of the samples caused formation of an additional type of hydroxyl group, possibly due to partial amorphisation of the surfaces of the quartz grains surface during the process. The results improve the basis for a knowledge-based processes development for the processing of high purity natural quartz.

Crystal structure transformation and lattice impurities migration of quartz during chlorine roasting

Removal Mechanism of Mineral Impurities in Molybdenum Concentrate Treatment Process

Removal of hydroxyl impurities in vein quartz by vacuum roasting

Purification of Quartz Via Low-Temperature Microwave Chlorinated Calcination Combined with Acid Leaching and its Mechanism

Effects of Alkyl Ether Amine and Calcium Ions on Fine Quartz Flotation and Its Guidance for Upgrading Vanadium from Stone Coal

Deep insight into the reductive roasting treatment on iron removing from quartz

Structural transformation and dehydroxylation of clay minerals in lithium-bearing clay

Purifying Technology of Preparing High Purity Quartz Sands from Vein Quartz Ore

Migration and Agglomeration of Chlorine in Dechlorination of Coal-Fired Flue Gas

Emission reduction treatment of chlorine-containing waste gas during the chlorination roasting process of lepidolite: thermodynamic analysis and mechanism investigation

Study on the Preparation of High-Quality Quartz and Its Mechanism by Combining Pretreatment with Metallurgy

Effect of ZnO on Crystallization of Zircon from Zirconium‐Based Glaze

Controlling Crystal Transformation Between Zeolite Zsm-5 and Mordenite Without Organic Structure-Directing Agent

A Review on Removal of Iron Impurities from Quartz Mineral

Structural evolution of water and hydroxyl groups during thermal, mechanical and chemical treatment of high purity natural quartz

Efficient Iron Removal to Produce High Purity Quartz Sand by Micro-Inclusion Bursting Using Microwave Pretreatment Combined with Different Acid

Gaseous fluorides formation mechanism in the roasting process of the fluorite-bearing iron concentrate

Non-isothermal kinetic studies of rubidium extraction from muscovite using a chlorination roasting-water leaching process

Microstructural evolution and crystallization mechanism of zircon from frit glaze

Understanding and controlling the key crystal phase transformation for recovery of sodium chloride from organic waste salt

Study on the integrated roasting process of kalsilite ore-CaCl2·2H2O system