Abstract:In this study, the process of carbon dioxide (CO2) capture directly from ambient air in a conventional monoethanolamine (MEA) absorption process was simulated and optimized using a rate-based model in Aspen Plus. The process aimed to capture a specific amount (148.25 Nm3/h) of CO2 from the air, which was determined by a potential application aiming to produce synthetic methane from the output of a 2.7 MW electrolyser (593 Nm3/h H2). We investigated the technical performance of the process by conducting a sensitivity analysis around different parameters such as air humidity, capture rate defined as a ratio of moles of CO2 captured during the process to the total mole of CO2 in the feed stream, CO2 loading of lean and rich absorption liquids and reboiler temperature, and evaluated the energy consumption and overall cost in this system. In order to meet the design requirement for standard packed columns, the rich absorption liquid was circulated to the top of the absorber. A capture rate of 50% was selected in this process as a baseline. At higher capture rates, the required energy per ton of captured CO2 increases due to a higher steam stripping rate, required in the desorber, and at lower capture rates, the size of equipment, in particular, absorber and blowers increases due to the need for processing a significantly larger volume of air at the given CO2 production volume. At the base case scenario, a reboiler duty of 10.7 GJ/tCO2 and an electrical energy requirement of 1.4 MWh/tCO2 were obtained. The absorber diameter and height obtained were 10.4 and 4.4 m, respectively. The desorber is found to be relatively small at 0.54 m in diameter and 3.0 m in height. A wash water section installed at top of the absorber decreased the MEA loss to 0.28 kg/ton CO2. However, this increased capital cost by around 60% resulting in CO2 capture costs of $1,691 per ton CO2 for the MEA base scenario. Based on the techno-economic analysis, assuming a non-volatile absorbent rather than MEA thereby avoiding a wash water section, and using an absorption column built from cheaper materials, the estimated cost per ton of CO2 produced was reduced to $676/tCO2. The overall cost range was between $273 and $1,227 per ton of CO2 depending on different economic parameters such as electricity ($20–$200/MWh) and heat price ($2–$20/GJ), plant life (15–25 years) and capital expenditure (±30%). In order to reduce the cost further, the use of innovative cheap gas-liquid contactors that operate at lower liquid to gas ratios is crucial.

High ethane content enables efficient CO 2 capture from natural gas by cryogenic distillation

Integrated ethane recovery and cryogenic carbon capture in a dual mixed refrigerant natural gas liquefaction process

Efficient CO<sub>2</sub> capture by a novel deep eutectic solvent through facile, one-pot synthesis with low energy consumption and feasible regeneration

Techno-economic Analysis on a Hybrid System with Carbon Capture and Energy Storage for Liquefied Natural Gas Cold Energy Utilization

Systematic Design and Optimization of a Membrane–Cryogenic Hybrid System for CO2 Capture

Cryogenic technology progress for CO2 capture under carbon neutrality goals: A review

Post-combustion CO2 capture from a natural gas combined cycle power plant using activated carbon adsorption

Simulation of H2S and CO2 Removal from IGCC Syngas by Cryogenic Distillation

Energy reduction and efficiency separation method of associated Gas in oilfield based on EOR-CO 2

High Selectivity CO 2 Capture from Biogas by Hydration Separation Based on the Kinetic Difference in the Presence of 1,1-Dichloro-1-fluoroethane

Energy‐effective carbon dioxide capture and storage design in hydrogen production from liquefied natural gas

The Removal of Benzene and Toluene in Natural Gas with Cryogenic Liquid Propane: Effects and a Cyclic Purification Process

Analysis and Optimization of Cryogenic Distillation Systems: For Reducing Distillation Energy Consumption

Novel fuel-efficient cryogenic carbon capture system for the combustion exhaust of LNG-powered ships

Novel ethane recovery process from natural gas using ZIF-8/water–glycol slurry: Techno-economic and energy consumption evaluation

Techno-Economic Assessment for CO2 Capture From Air Using a Conventional Liquid-Based Absorption Process

Energy consumption and economic analysis of CO 2 capture from flue gas by membrane separation coupled with hydrate method

Recovery enhancement of liquid hydrocarbons in dew point control unit of natural gas processing plant

Low-grade heat utilization and CO2liquefaction process based on LiBr absorption refrigeration

Process Simulation and Integration of Natural Gas Condensate Recovery Using Ethane–Propane Refrigerant Mixture

Environmentally Friendly Production of Petroleum Systems with High Co2 Content