Abstract:The key to recovering waste LiFePO 4 (LFP) is the recovery of lithium; however, the effective and synchronous recovery of phosphorus and iron resources still needs to be achieved. In this paper, a new process was proposed for recovering phosphorus and iron from the lithium extraction slag (LES) of waste LFP by the leaching and precipitation method. Based on the thermodynamic analysis of Fe 3+ and PO 4 3− and XRD results, the experimental conditions were discussed in detail. There were three stable regions when the solution pH value was from 0 to 5, no precipitation at pH = 0–0.664, stable existence of FePO 4 (s) at pH = 0.664–1.203, coexistence of FePO 4 (s), and AlPO 4 (s) when pH > 1.203, respectively. The leaching solution of LES by hydrochloric acid could prepare FePO 4 ·2H 2 O under the following optimal conditions: 95°C, pH 1.5, feeding speed 1.5 mL min −1 . The synthesised iron phosphate was pure and distributed in flakes. Additionally, the discharge capacity of the LiFePO 4 /C prepared by the regenerative FePO 4 ·2H 2 O was 147 mAh g −1 at 0.1 C and showed good cycle stability at 1 C. The method not only recovers FePO 4 from the LES but also shows simple operation and high efficiency. La clé pour récupérer les déchets de cathode LiFePO 4 (LFP) est la récupération du lithium, mais il est encore nécessaire d'atteindre une récupération efficace du phosphore et du fer de manière synchrone. Dans cet article, nous proposons un nouveau procédé de récupération du phosphore et du fer des scories d'extraction du lithium (LES) des déchets de LFP par lixiviation et précipitation. Sur la base de l'analyse thermodynamique des résultats de Fe 3+ et de PO 4 3− et de XRD, on a discuté en détail des conditions du procédé. Il y avait trois régions stables au pH = 0–5, aucune précipitation au pH = 0–0.664, existence stable de FePO 4 (s) au pH = 0.664–1.203, coexistence de FePO 4 (s) et AlPO 4 (s) au pH >1.203, respectivement. La solution de lixiviation du LES par l'acide chlorhydrique pourrait préparer du FePO 4 •2H 2 O dans les conditions optimales suivantes: 95°C, pH = 1.5, vitesse d'alimentation de 1.5 mL min −1 . Le phosphate de fer synthétisé était pur et distribué en flocons. De plus, la capacité de décharge du LiFePO 4 /C préparé par le FePO 4 •2H 2 O régénératif était de 147 mAh g −1 à 0.1 C et montre une bonne stabilité du cycle à 1 C. Non seulement la méthode récupère le FePO 4 du LES, mais elle présente également un fonctionnement simple et de haute efficacité.

Recovery of Phosphate From Industrial Wastewater by Homogeneous Ferrous Phosphate Crystallization and application for synthesis of Lithium Iron Phosphate Battery

Removal of impurity metals as phosphates from Lithium-ion battery leachates

A Facile Recovery Process for Cathodes from Spent Lithium Iron Phosphate Batteries by Using Oxalic Acid

Preparation of Iron Phosphate Battery Materials from Industrial Ferrous Sulfate Waste by Liquid Phase Method

The recovery of high purity iron phosphate from the spent lithium extraction slag by a simple phosphoric acid pickling

Recovery of cathode materials from waste lithium iron phosphate batteries through ultralow temperature treatment and mechanical separation

Synthesizing LiFePO4 by phosphate & iron recovered from sludge-incinerated ash and Li extracted from concentrated brines

A Facile Route for the Efficient Leaching, Recovery, and Regeneration of Lithium and Iron from Waste Lithium Iron Phosphate Cathode Materials

A fast and efficient method for selective extraction of lithium from spent lithium iron phosphate battery

A green process for phosphorus recovery from spent LiFePO4 batteries by transformation of delithiated LiFePO4 crystal into NaFeS2

Selective recovery of lithium from lithium iron phosphate

Sequential separation and recovery of phosphorus and lithium from lithium phosphate slag by selective extraction-precipitation

Study on selective recovery of lithium ions from lithium iron phosphate powder by electrochemical method

A facile way to regenerate FePO4∙2H2O precursor from spent lithium iron phosphate cathode powder: Spontaneous precipitation and phase transformation in an acidic medium

Recovery of Lithium from Industrial Li-Containing Wastewater Using Fluidized-Bed Homogeneous Granulation Technology

Efficient recovery of phosphorus and iron from the lithium extraction slag by the leaching precipitation method

Removal and recovery of phosphorus and fluorine in process water from water based direct physical lithium-ion battery recycling

Study on efficient and synergistic leaching of valuable metals from spent lithium iron phosphate using the phosphoric acid-oxalic acid system

Green and High-Yield Recovery of Phosphorus from Municipal Wastewater for LiFePO4 Batteries

Ferrioxalate photolysis-assisted green recovery of valuable resources from spent lithium iron phosphate batteries

Study on the behavior of impurity removal from lithium iron phosphate slag using the ultrasonic-assisted sulphuric acid leaching