Abstract:In a spontaneous coal combustion environment and in the coal chemical process, multiple gases, such as CH4, H2, and CO, coexist, and explosion accidents are prone to occur. The causes of these disasters and the explosion characteristics are key to formulating preventive measures. To explore the effect of H2/CO on the explosion pressure and thermal behavior of methane-air, CH4 with initial volume fractions of 7, 9.5, and 12%, which correspond to three states of oxygen enrichment, equivalence ratio, and oxygen depletion, was selected. Moreover, a mixed fuel system is composed of H2/CO with different volume ratios. A 20 L spherical gas explosion experimental system was used to test the peak explosion overpressure P max, the maximum explosion overpressure rise rate (dP/dt)max, and the corresponding time parameters of the H2/CO-CH4 mixed system. Combined with the thermodynamic calculation model, laminar burning velocity S L, explosion heat loss q tra, and other parameters were obtained. The results show that due to the existence of the damping effect, CO has the dual characteristic of promoting or weakening methane explosions. Compared with CO, the effect of H2 on the methane explosion is more significant, and the improvement or weakening of the laminar combustion rate of the reaction system by CO "lags" behind that of H2. The heat loss in the process of a gas explosion is affected by factors such as the heat release rate, the propagation speed of the combustion wave, and the heat dissipation effect of the container wall. When H2/CO increases the laminar burning velocity of the mixed system, the heat loss decreases accordingly. This study also found that the laminar burning velocity model of the mixed gas based on the ideal spherical flame propagation theory is not fully applicable to the H2/CO/CH4 mixed system in a spherical closed space, and the calculation results have large errors when the mixed system is close to the upper limit of the explosion.

Influence of equivalence ratio and H 2 blended ratio on explosion propagation characteristics of DME/H 2 blended gas in closed narrow space

Effects of Hydrogen Blending Ratio and Equivalence Ratio on the Dynamic Characteristics of Deflagration Shock Waves of CH 4 /H 2 Mixtures

Effect of hydrogen addition on explosion characteristics of premixed methane/air mixture under different equivalence ratio distributions

Experimental study on explosion behavior of propane-dimethyl ether blends

Impacts of hydrogen fraction and equivalence ratio on the explosion characteristics of ethanol/hydrogen mixtures

Experimental study on the flame-dual field overpressure coupling evolution characteristics of LPG/DME blended gas explosion venting

Characteristics of Explosion Hazards in Methane–Air Mixtures Diluted by Hydrogen

Investigation of C2H6, C2H4, CO and H2 on the explosion pressure behavior of methane/blended fuels

The flammability limits and explosion behaviours of hydrogen-enriched methane-air mixtures

The effects of different equivalence ratios and initial pressures on the explosion of methane/air premixed gas in closed space

A comparative study of the explosion behaviors of H2 and C2H4 with air, N2O and O2

Experimental Study of the Influence of H2/CO on the CH4 Explosion Pressure and Thermal Behaviors

Study on the explosion characteristics and flame propagation of hydrogen-methane-air mixtures in a closed vessel

Effect of dimensionless vent ratio on the flame-shock wave evolution dynamics of blended LPG/DME gas explosion venting

The explosion thermal behavior of H2/CH4/air mixtures in a closed 20 L vessel

Hydrogen influence on confined explosion characteristics of hydrocarbon-air mixtures at sub-atmospheric pressures

Investigation of the Effects of Hydrogen Addition on Explosion Characteristics and Pressure Fluctuations of Ethyl Acetate

Investigation on Explosion Characteristics of Hydrogen-Methane-Ethanol Mixtures

The Explosion Characteristics of Methane, Hydrogen and Their Mixtures: A Computational Study

Evaluation of hydrogen-blended methane explosion

Effects of mixing CO and H 2 as main components on the explosion characteristics and dynamics properties of methane