Abstract:The incorporation of ethanol into hydrocarbon fuels for use is attracting increasing interest and it is necessary to investigate its inherent flame instability for better application in combustion units. The instability of hydrogen-methane-ethanol spherically expanding flame has been investigated at an initial temperature of 400 K, initial pressures of (2–4 bar), ethanol fraction of (20%, 50%, 80%), and equivalence ratios ( Ф ) of (0.7–1.4) using the constant volume combustion chamber (CVCC). High-speed schlieren technology was used to record flame propagation images. The effects of hydrodynamic and thermal-diffusion effect on the inherent instability of the flame were investigated. As the ethanol ratio increased, the hydrodynamic effect was enhanced. The thermal-diffusion effect was discovered to stabilize the flame surface under all conditions, as judged jointly by the effective Lewis number and the critical Lewis number. The critical conditions (critical radius and Peclet number) at the onset of unstability were evaluated, and it was found that the flames were more prone to flame instability at higher pressures. The critical Peclet number increased with the increase in the equivalence ratio when the ethanol ratio was 20%, and showed the opposite trend when the ethanol ratio was 50% and 80%. In addition, as the ethanol ratio increases, the stability of the lean mixtures flame increases, while the rich mixtures flame suffers from early onset of instability. The theoretical and experimental results were consistent, with some differences at Ф = 1.4. An empirical correlation formula for the critical Peclet number ( Pec ) and Markstein number ( M b ) was further proposed ( Pec = 18.03 M b +214.78). Finally, the Karlovitz number was used to study the instability behavior of the flame. The critical Karlovitz number ( Ka c ) decreased with increasing M b and the tendency of the flame to suffer from instability diminished, and the following correlation was obtained Kac=0.05635×e−0.13852Mb . Furthermore, the flame was more unstable in rich mixtures, this was consistent with the conclusion of instability derived from the critical radius.

Investigation on Explosion Characteristics of Hydrogen-Methane-Ethanol Mixtures

Impacts of hydrogen fraction and equivalence ratio on the explosion characteristics of ethanol/hydrogen mixtures

The Explosion Characteristics of Methane, Hydrogen and Their Mixtures: A Computational Study

Investigation of cellularization characteristics of hydrogen-methane-ethanol expanding spherical flame at elevated pressures

Investigation of the Effects of Hydrogen Addition on Explosion Characteristics and Pressure Fluctuations of Ethyl Acetate

The explosion thermal behavior of H2/CH4/air mixtures in a closed 20 L vessel

Experimental study on the explosion characteristics of methylcyclohexane/toluene-air mixtures with methanol addition at elevated temperatures

The flammability limits and explosion behaviours of hydrogen-enriched methane-air mixtures

Investigation of C2H6, C2H4, CO and H2 on the explosion pressure behavior of methane/blended fuels

Study on the explosion characteristics and flame propagation of hydrogen-methane-air mixtures in a closed vessel

Study of the Explosive Behaviour of NH3/H2/air Mixtures

Investigations on Explosion Characteristics of Ethyl Acetate

Experimental and Numerical Studies on the Explosion Characteristics of Ethanol–Air Mixtures under Aviation Conditions

Characteristics of Explosion Hazards in Methane–Air Mixtures Diluted by Hydrogen

Hydrogen influence on confined explosion characteristics of hydrocarbon-air mixtures at sub-atmospheric pressures

Explosion Characteristics of Hydrous Bio-Ethanol in Oxygen-Enriched Air

Investigations on Methyl Pentanoate-Air Mixtures Confined Explosion and Cellularity

Investigation of cellular characteristics of hydrogen-ethanol flame at elevated temperatures and pressures

Experimental study on explosion behavior of propane-dimethyl ether blends

Experimental Study on the Explosion and Flame Emission Behaviors of Methane-Ethylene-air Mixtures

Effect of hydrogen addition on explosion characteristics of premixed methane/air mixture under different equivalence ratio distributions