Abstract:The study on the temperature-dependent kinetic behavior of intermetallic compounds (IMCs) in Mg–Al–Zn (AZ) series alloy system is important since its close interrelation with the microstructure evolution under various alloying conditions as well as the T-dependent performance. However, there is a very lack of experimental study on the diffusion kinetics of the ternary IMCs in the AZ series alloy systems. The current work combines the diffusion couple technique and numerical inverse method to investigate the T-dependent kinetic coefficients, i.e., the parabolic growth constant (PGC) and interdiffusion coefficients, for ϕ-Mg5Al2Zn2 ternary IMC in the Mg–Al–Zn alloy system. The Arrhenius formula of both PGC and main interdiffusivities is obtained, i.e., ϕkp=5.48×10-5exp120010RT\documentclass[12pt]{minimal}\usepackage{amsmath}\usepackage{wasysym}\usepackage{amsfonts}\usepackage{amssymb}\usepackage{amsbsy}\usepackage{mathrsfs}\usepackage{upgreek}\setlength{\oddsidemargin}{-69pt}\begin{document}$${}_{{}}^{\phi } k_{p} = 5.48 \times 10^{ - 5} \exp \left( {\frac{120010}{{RT}}} \right)$$\end{document} m2/s, ϕD~MgMgAl=3.48×10-10exp50420RT\documentclass[12pt]{minimal}\usepackage{amsmath}\usepackage{wasysym}\usepackage{amsfonts}\usepackage{amssymb}\usepackage{amsbsy}\usepackage{mathrsfs}\usepackage{upgreek}\setlength{\oddsidemargin}{-69pt}\begin{document}$${}_{{}}^{\phi } \tilde{D}_{{{\text{MgMg}}}}^{Al} = 3.48 \times 10^{ - 10} \exp \left( {\frac{50420}{{RT}}} \right)$$\end{document} m2/s and ϕD~ZnZnAl=2.87×10-7exp91440RT\documentclass[12pt]{minimal}\usepackage{amsmath}\usepackage{wasysym}\usepackage{amsfonts}\usepackage{amssymb}\usepackage{amsbsy}\usepackage{mathrsfs}\usepackage{upgreek}\setlength{\oddsidemargin}{-69pt}\begin{document}$${}_{{}}^{\phi } \tilde{D}_{{{\text{ZnZn}}}}^{Al} = 2.87 \times 10^{ - 7} \exp \left( {\frac{91440}{{RT}}} \right)$$\end{document} m2/s, based on which a numerical reproduction of the experimentally determined IMC growth is performed for verification. By comparing the current experimental and calculation results, the rate-controlling factor of the temperature-dependent diffusion growth of ϕ ternary IMC in the Mg–Al–Zn system is further discussed.

Diffusion behaviour and mechanical properties of binary Mg–Gd system

Reactive Diffusion in Mg–Gd Binary System at 773 K

Investigation on the temperature-dependent diffusion growth of intermetallic compounds in the Mg-Al-Zn system: Experiment and modeling

Evolutions of Microstructure and Mechanical Properties in Mg–5Li–1Zn–0.5Ag–0.5Zr–xGd Alloy

Microstructures and Mechanical Properties of the Mg–4.5Zn–xGd (x = 0, 2, 3 and 5) Alloys

Microstructure and Mechanical Properties of Mg–9Li–3Al–xGd Alloys

A good balance between strength and ductility in Mg–Zn–Mn-Gd alloy

Influences of Gd on the Microstructure and Strength of Mg–4.5Zn Alloy

The Effect of Gd and Zn Additions on Microstructures and Mechanical Properties of Mg-4sm-3nd-Zr Alloy

Investigations on Microstructure and Mechanical Properties of Cast Mg-Gd-Y-Zn-Zr-Nd Alloy

Interfacial microstructure, mechanical properties and strengthening mechanism of Mg/Al bimetallic composites produced by a novel compound casting with the addition of Gd

First-principle Studies on the Mechanical, Thermodynamic and Electronic Properties of Β″-Mg3gd and Β′-Mg7gd Alloys under Pressure

Study on diffusion characteristics of Al-Cu systems and mechanical properties of intermetallics

First-principles study of binary and ternary phases in Mg-Gd-Ni alloys

On the temperature-dependent diffusion growth of φ-Mg5Al2Zn2 ternary intermetallic compound in the Mg–Al–Zn system

Study on the Mutual Effect of La and Gd on Microstructure and Mechanical Properties of Mg-Al-Zn Extruded Alloy

Microstructures and Properties of Mg–7Gd Alloy Containing Y

Interdiffusion and atomic mobility of the Mg-Ag-Zn system

Effect of dilute atom Gd on critical resolved shear stress and anisotropic deformation mechanism of Mg-Gd alloy

Effect of Gd content on microstructure and dynamic mechanical properties of solution-treated Mg−xGd−3Y−0.5Zr alloy

Microstructure of as-cast Mg-4.2Zn-0.8Y (at.%) alloys containing Gd