Abstract:The transition from traditional wastewater treatment plants to biorefineries represents an environmentally and economically sustainable approach to extracting valuable compounds from waste. Sewage sludge produced from wastewater treatment is incinerated or disposed of in specific landfills. Repurposing this waste material to recover valuable resources could help lower disposal costs and reduce environmental impact by producing other beneficial polymers. Microorganisms present in the sewage sludge can ferment organic pollutants, producing volatile fatty acids (VFA), precursors for biopolymers that could be used as an alternative to petroleum-derived plastics. To boost VFA production during sewage sludge fermentation, it is necessary to understand the operating microbial community and its metabolic capacities in anaerobic conditions. This study presents the influence of the headspace volume on the microbial community and the VFA production to define the best operational parameters in a 225 L pilot plant fermenter. The wasted sewage sludge was withdrawn from an oxic-settling-anaerobic plant that collected wastewater from the canteen and dormitory of the UNIPA Campus (Palermo University, Italy) and incubated using a 40% and a 60% headspace volume. The microbial community was analysed before and after the fermentation process through metataxonomic analysis, and VFA yields were determined by gas chromatography analysis. Our results showed that the 40% headspace volume induced a tenfold higher VFA production than the 60% headspace volume, modulating the microbial community's efforts to establish a VFA-producing factory. Notably, at 40% headspace, the relative abundance of bacteria, like Proteobacteria, Firmicutes, Actinobacteria, and Chloroflexi, significantly increased, as well as the relative abundance of Bacteroidetes and Verrucomicrobia decreased during the fermentation process. This result is consistent with the selection of efficient VFA-producing bacteria that lead to increased VFA yields that are not obtained at 60% headspace. Thus, reducing headspace is a promising strategy that can be implemented, even in full-scale plants, to optimise the wastewater reuse process and maximise VFA production to produce bioplastics, like polyhydroxyalkanoate, for the transition from linear wastewater treatment plants to circular biorefineries.

Importance of digester’s headspace geometry for the efficient H2S removal through microaeration; experimental and simulation study

Microaeration for hydrogen sulfide removal during anaerobic treatment: a review

Headspace micro-oxygenation as a strategy for efficient biogas desulfurization and biomethane generation in a centralized sewage sludge digestion plant

Performance and microbial community analysis of anaerobic sludge digestion enhanced by in-situ microaeration

Optimising flow and mixing in a full-scale gas-mixed anaerobic digester by integrating sludge rheological data using computational fluid dynamics

Axisymmetric Gas Flow Model for Bioreactor Landfills Incorporating MSW Compression and Leachate Recirculation

A modeling and simulation study of anaerobic digestion in plug-flow reactors

Effect of micro-aeration on anaerobic digestion of primary sludge under septic tank conditions

Numerical modelling of surface aeration and N2O emission in biological water resource recovery

Exploring the multiphase flow and mass transfer characteristics for desulfurization in an upflow biogas reactor

Study on Side-entering Agitator Flow Field Simulation in Large Scale Biogas Digester

Application of Hydrodynamic Cavitation in the Disintegration of Aerobic Granular Sludge—Evaluation of Pretreatment Time on Biomass Properties, Anaerobic Digestion Efficiency and Energy Balance

Dynamic α-factor models for fine-bubble- and surface aeration – impact of settleability and implications on N 2 O emission

Improvement of Biogas Production Utilizing a Complex Anaerobic Digestion Model and Gradient-Based Optimization

Computational fluid dynamic (CFD) modelling in anaerobic digestion: General application and recent advances

Design and structural parameter optimization of Venturi-type microbubble reactor for wastewater treatment by CFD simulation

Numerical simulation of trickle bed reactors for biological methanation

Effect of micro-aeration on syntrophic and methanogenic activity in anaerobic sludge

The effects of headspace volume reactor on the microbial community structure during fermentation processes for volatile fatty acid production

Quantitative relationships for the impact of gas sparging conditions on membrane fouling in anaerobic membrane bioreactor

Numerical model for simulating the hydraulic parameters of the aeration system ensuring equal oxygenation of the compost heap