Abstract:Anaerobic digestion (AD) produces useful biogas and waste streams with high levels of dissolved methane (CH4) and ammonium (NH4+), among other nutrients. Membrane biofilm reactors (MBfRs), which support dissolved methane oxidation in the same reactor as simultaneous nitrification and denitrification (ME-SND), are a potential bubble-less treatment method. Here, we demonstrate ME-SND taking place in single-stage, AD digestate liquid-fed MBfRs, where oxygen (O2) and supplemental CH4 were delivered via pressurized membranes. The effects of two O2 pressures, leading to different O2 fluxes, on CH4 and N removal were examined. MBfRs achieved up to 98% and 67% CH4 and N removal efficiencies, respectively. The maximum N removal rates ranged from 57 to 94 mg N L-1 d-1, with higher overall rates observed in reactors with lower O2 pressures. The higher-O2-flux condition showed NO2- as a partial nitrification endpoint, with a lower total N removal rate due to low N2 gas production compared to lower-O2-pressure reactors, which favored complete nitrification and denitrification. Membrane biofilm 16S rRNA amplicon sequencing showed an abundance of aerobic methanotrophs (especially Methylobacter, Methylomonas, and Methylotenera) and enrichment of nitrifiers (especially Nitrosomonas and Nitrospira) and anammox bacteria (especially Ca. Annamoxoglobus and Ca. Brocadia) in high-O2 and low-O2 reactors, respectively. Supplementation of the influent with nitrite supported evidence that anammox bacteria in the low-O2 condition were nitrite-limited. This work highlights coupling of aerobic methanotrophy and nitrogen removal in AD digestate-fed reactors, demonstrating the potential application of ME-SND in MBfRs for the treatment of AD's residual liquids and wastewater. Sensor-based tuning of membrane O2 pressure holds promise for the optimization of bubble-less treatment of excess CH4 and NH4+ in wastewater.

Headspace micro-oxygenation as a strategy for efficient biogas desulfurization and biomethane generation in a centralized sewage sludge digestion plant

Advances in Technologies for in Situ Desulfurization of Biogas

Anoxic desulphurisation of biogas from full-scale anaerobic digesters in suspended biomass bioreactors valorising previously nitrified digestate centrate

Biodesulfurization of landfill biogas by a pilot-scale bioscrubber: Operational limits and microbial analysis.

Characterisation and cleaning of biogas from sewage sludge for biomethane production

Removal of Hydrogen Sulfide in Biogas by DBD Plasma

Performance and Optimization of Integrated Biogas Bio-desulfurization Reactor

Pilot-scale in-situ biomethanation of sewage sludge: Effects of gas recirculation method

Sludge reduction, nitrous oxide emissions, and phosphorus removal by oxic-settling-anaerobic (OSA) process: the effect of hydraulic retention time

Integrating biodegradation and ozone-catalysed oxidation for treatment and reuse of biomass gasification wastewater

H2S oxidation coupled to nitrate reduction in a two-stage bioreactor: Targeting H2S-rich biogas desulfurization

Investigation of intermittent aeration and oxic settling anaerobic process combination for nitrogen removal and sewage sludge reduction

Characterization of Sulfide-Oxidizing Microbial Mats Developed Inside a Full-Scale Anaerobic Digester Employing Biological Desulfurization

Application of molecular techniques to evaluate the methanogenic archaea and anaerobic bacteria in the presence of oxygen with different COD:sulfate ratios in a UASB reactor

Pretreatment of sludge with sodium iron chlorophyllin-H2O2 for enhanced biogas production during anaerobic digestion

Sewage sludge minimisation by OSA-MBR: A pilot plant experiment

Mitigation of diffuse CH4 and H2S emissions from the liquid phase of UASB-based sewage treatment plants: challenges, techniques, and perspectives

Microaeration for hydrogen sulfide removal during anaerobic treatment: a review

Performance and microbial community analysis of anaerobic sludge digestion enhanced by in-situ microaeration

Anaerobic Digestion for Simultaneous Sewage Sludge Treatment and CO Biomethanation: Process Performance and Microbial Ecology

Treatment of Anaerobic Digester Liquids via Membrane Biofilm Reactors: Simultaneous Aerobic Methanotrophy and Nitrogen Removal