Abstract:The extreme ultraviolet (EUV) emission characteristics from Sn plasma for lithography produced by a pulse discharge CO2 laser was investigated under different conditions. Extreme ultraviolet spectral measurements were made throughout the wavelength region of 6.5 nm to 16.8 nm using a grazing incidence flat-field spectrograph coupled with an X-ray charge-coupled device camera for detection of time-integrated spectra. The dependence of spectral properties of the EUV emission on pulse duration, incidence pulse energy, and buffer gas pressure was investigated. The results show that the peak of EUV spectra was located at 13.5 nm. The intensity of EUV emission increased with increasing laser energy ranging from 30 mJ to 600 mJ in a nonlinear manner with saturation effect. The critical energy of incident pulse laser for the generation of EUV emission is near 30 mJ in our experiment. The highest conversion efficiency of 1.2% in producing 13.5 nm EUV light with 0.27 nm bandwidth was achieved at pump energy of 425 mJ. The EUV spectra from a plate target produced by laser pulse with full width at half maximum range from 50 ns to 120 ns were recorded and negligible differences in their spectral features noticed even though higher spectral intensity was observed by shorter pulse duration. The 2% in-band EUV intensity with 52 ns pulse duration was 1.6 times higher than that with 120 ns pulse duration due to the increase in laser intensity. It was also found that the detected EUV spectral intensity rapidly decreased with increasing buffer air pressure, and the EUV emission could be totally absorbed at the pressure of 200 Pa, while weak EUV emission could be still detected at the buffer He gas pressure of 7 X 10(4) Pa. The experimental results showed that the absorption coefficient of 13.5 nm light at air buffer gas pressure of 100 Pa was 3.0 m(-1), while the absorption coefficient was 0.96 m(-1) at the same He buffer gas pressure.

Efficient photo-dissociation-induced production of hydrogen radicals using vacuum ultraviolet light from a laser-produced plasma

Absolute density measurement of hydrogen radicals in XUV induced plasma for tin contamination cleaning via laser-induced fluorescence

Time-resolved Measurement of Radical Populations in Extreme-Ultraviolet-light-induced Hydrogen Plasma

Tin removal by an annular surface wave plasma antenna in an extreme ultraviolet lithography source

Miniature Plasma Source for In-Situ Scanner Cleaning

A Vacuum Ultraviolet Photoionization Time‐of‐flight Mass Spectrometer with High Sensitivity for Study of Gas‐phase Radical Reaction in a Flow Tube

Physics of laser-driven tin plasma sources of EUV radiation for nanolithography

Laser Etching Processes : Towards Sub-Picosecond X-UV Irradiation

Synergistic Formation of Radicals by Irradiation with Both Vacuum Ultraviolet and Atomic Hydrogen: A Real-Time In Situ Electron Spin Resonance Study

Exploring photoionization of gas-phase free radicals with a widely tunable VUV laser at moderate spectral resolution

Extreme Ultraviolet Radiation from Z-pinch Plasmas for Next Generation Lithography

Simulation of extreme ultraviolet radiation of laser induced discharge plasma

Tunable VUV Photochemistry Using Vacuum Ultraviolet Free Electron Laser Combined with H-atom Rydberg Tagging Time-of-flight Spectroscopy.

VUV diagnostic of electron impact processes in low temperature molecular hydrogen plasma

Nonnegligible Generation of Hydroxyl Radicals from UVC Photolysis of Aqueous Nitrous Oxide.

Characteristics of Extreme Ultraviolet Emission from Tin Plasma Using Co2 Laser for Lithography

Measurements of ion fluxes in extreme ultraviolet-induced plasma of new EUV-beam-line 2 nanolithography research machine and their applications for optical component tests

Single-shot 3D Imaging of Hydroxyl Radicals in the Vicinity of a Gliding Arc Discharge

Application of Laser Dispersion Method in Apparatus Combining H Atom Rydberg Tagging Time-of-flight Technique with Vacuum Ultraviolet Free Electron Laser

Hydroxyl radical dynamics in a gliding arc discharge using high-speed PLIF imaging

Photodissociation Dynamics Of H2o At 111.5 Nm By A Vacuum Ultraviolet Free Electron Laser