Abstract:Due to environmental constraints, the Organic Rankine Cycle (ORC) is widely used to generate electricity from low grade heat sources. In ORC processes, the working fluid is an organic substance, which has a better thermodynamic performance than water for low grade heat recovery. The design of the turbine which is the key component in the ORC system strongly depends on the operating conditions and on the scale of the facility. This paper presents an experimental study on a prototype of an axial-flow turbine integrated into a regenerative ORC system with R123 as working fluid. The power output is 10kW scale, and the single-stage turbine is selected. The turbine is specially designed and manufactured, and a generator is connected to the turbine directly. In the experiment, the turbine is tested under different inlet pressure conditions (0.6–1.5MPa), different inlet temperature conditions (80–150°C) and different flow rate conditions. The experimental data such as the pressures, temperatures of the turbine inlet and outlet, flow rate, rotational speed, and electrical power generation are analyzed to find their inner relationships. During the test, the turbine rotational speed could reach more than 3010 r/min, while the design rotational speed is 3000 r/min. The isentropic efficiency of the turbine could reach 53%. The maximum electrical power generated by the turbine-generator is 6.57KW. From the test data the peak value of the temperature difference between the inlet and the outlet of the turbine is 53 °C, and the expansion ratio reaches about 11. The computational fluid dynamics (CFD) solvers is also used to analyze the performance of the turbine. The distributions of the pressure, Mach number, and static entropy in the turbine flow passage component are examined and the reasons are also obtained. This study reveals the relationships between the performance of the axial-flow turbine and its inlet and outlet vapor conditions. The experiment results and the CFD results lay a foundation for using this type turbine in the ORC systems which product electrical power from a few KW to MW.

The organic triangle cycle experience and status

Investigation of an Innovative Cascade Cycle Combining a Trilateral Cycle and an Organic Rankine Cycle (TLC-ORC) for Industry or Transport Application

Experimental Investigations on Dynamic Performance of Organic Rankine Cycle Integrated with Latent Thermal Energy Storage under Transient Engine Conditions

Cooperative Optimization of System Parameters and Heat Exchanger Structure for Geothermal Organic Rankine Cycle

Comparison study of Trilateral Rankine Cycle, Organic Flash Cycle and basic Organic Rankine Cycle for low grade heat recovery

Working Fluid Selection for a Small-Scale Organic Rankine Cycle Recovering Engine Waste Heat

Experimental study of a miniature organic Rankine cycle unit using ocean thermal energy

Thermodynamic analysis and turbine design of a 100 kW OTEC-ORC with binary non-azeotropic working fluid

Thermodynamic Investigation and Economic Evaluation of a High-Temperature Triple Organic Rankine Cycle System

Development and Dynamic Characteristics of an Organic Rankine Cycle

Performance Evaluation of A Turbine Used in A Regenerative Organic Rankine Cycle

Systematic Fluid Selection for Organic Rankine Cycles and Performance Analysis for a Combined High and Low Temperature Cycle

Experimental Investigation on a Small-Scale ORC System with a Pump Driven by Internal Multi-Potential

Power Generation Systems Using Continuous Blowdown Waste Heat From Drum Boilers Driving an Organic Rankine Cycle

Performance improvement of ocean thermal energy conversion organic Rankine cycle under temperature glide effect

Energetic and Exergetic Investigation of an Organic Rankine Cycle at Different Heat Source Temperatures

Feasibility study of the high‐temperature organic Rankine cycle in combined heat and power state from energy, exergy, and economic point of view

Organic Rankine cycle performance evaluation and thermoeconomic assessment with various applications part I: Energy and exergy performance evaluation

Comparative Study of Alternative ORC-based Combined Power Systems to Exploit High Temperature Waste Heat

Investigation on A Small-Scale Pumpless Organic Rankine Cycle (orc) System Driven by the Low Temperature Heat Source

Operation of an Organic Rankine Cycle Dependent on Pumping Flow Rates and Expander Torques