Power Generation Systems Using Continuous Blowdown Waste Heat From Drum Boilers Driving an Organic Rankine Cycle

LIU Qiang,DUAN Yuanyuan,WAN Xucai

DOI: https://doi.org/10.13334/j.0258-8013.pcsee.2013.35.006

2013-01-01

Abstract:A power generation system which used the continuous blowdown waste heat to drive an organic Rankine cycle (ORC) was developed to improve the energy efficiency. The blowdown waste heat was recovered by organic fluid, and then generates power by expansion through a turbine. The analysis model of thermal performance for the system was established. The performance of seven ORC working fluids including R227ea, RC318, R236ea, R245fa, R245ca, R123 and R113 were optimized using the GRG algorithm, and the maximum power output was obtained. The results show that the optimum turbine inlet temperature increases as the critical temperature of the working fluid decreases for the o2 cycle which has saturated vapor entering the turbine. However, the superheating in the o3 cycle reduces the waste heat utilization ratio. Supercritical ORC improves the match of temperature profiles between the heat source and the working fluid, which helps to increase the system power output. But the high operation pressure and heat transfer deterioration due to the large specific heat near the critical point must be considered in the system design. The thermal performance and the power output of R236ea are better than the six other fluids.