Abstract:Treating hydroxyapatite (HAP) with sulfonic acid without structural destruction remains challenging owing to the sensitivity of HAP to acidic pH. In this work, natural derived HAP was prepared using natural phosphate via a dissolution/precipitation process. Notwithstanding the challenge, the prepared HAP was treated with three concentrations of chlorosulfonic acid in dichloromethane to prepare HAP-S1, HAP-S2 and HAP-S3 depending on the acid content under carefully controlled conditions. The treatment of HAP with the lowest acid concentration led to the preservation of the apatite framework with surface modification of sulfonic acid groups. As the acid concentration increased, HAP, CaHPO4 and CaSO4 were obtained. A further increase in the acid concentration led to the formation of CaSO4 with the coexistence of Ca(H2PO4)2·H2O. Subsequently, the catalytic activity of HAP-S1 was evaluated in oleic acid esterification under microwave irradiation, resulting in a yield of up to 87% under optimized conditions of 10 wt% of catalyst to oleic acid weight, 10 : 1 methanol to oleic acid molar ratio, and 40 min reaction duration under microwave irradiation at 150 °C. The activity of HAP-S1 was attributed to the active S[double bond, length as m-dash]O and S-O-H functional groups, and a possible mechanism of acid-catalyzed esterification is proposed. The catalyst was also tested in the transesterification reaction of rapeseed oil, achieving a conversion of 40.2% after 60 min reaction duration under microwave irradiation. Furthermore, the catalyst was evaluated in a two-step esterification reaction to investigate its activity towards acidified feedstocks. Results showed that after two successive runs, acidity was reduced by 79.6% with a total FAME yield of 40.13%. The obtained results indicate that this catalyst, being an acid catalyst, is more suitable for direct esterification.

Microwave-Assisted Enzymatic Esterification Production of Emollient Esters

MICROWAVE FACILITATED THE SYNTHESIS OF ISOPROPYL MYRISTATE AND PALMITATE USING HETEROGENEOUS CATALYST

In Situ Ethyl Ester Production from Wet Algal Biomass under Microwave-Mediated Supercritical Ethanol Conditions

Biolubricant Production of 2‐ethylhexyl Palmitate by Transesterification over Unsupported Potassium Carbonate

Eco-friendly isopropyl myristate production in a fixed bed reactor: Leveraging energy-saving enzymatic techniques with a comprehensive evaluation of techno-economic feasibility

Microwave-assisted Pyrolysis of Methyl Ricinoleate for Continuous Production of Undecylenic Acid Methyl Ester (UAME)

Clean production of isopropyl myristate: A cutting-edge enzymatic approach with a holistic techno-economic evaluation

Pyrolysis of Methyl Ricinoleate by Microwave-Assisted Heating Coupled with Atomization Feeding

Exploring Whole Cells of Rhizopus oryzae for Efficient Synthesis of Emollient Esters: Bioesters for Cosmetics

Optimization of Methyl Ester Through Simultaneous Esterification –Transesterification Reactions Using Waste Cooking Oil as Raw Material

Optimization and kinetic study of N‐methyldiethanolamine‐based esterquats production

Synthesis of 2- Ethylhexyl Palmitate under Microwave Irradiation

Microwave-driven oleic acid esterification over chlorosulfonic acid-treated hydroxyapatite: synergism for intensified biodiesel production

Fast and accurate preparation fatty acid methyl esters by microwave-assisted derivatization in the yeast Saccharomyces cerevisiae

Dielectric Properties During Microwave-Induced Interesterification Reactions for Biodiesel and Triacetin Production

Microwave-assisted synthesis of trimethylolpropane triester (bio-lubricant) from camelina oil

Microwave-assisted enzymatic synthesis of geraniol esters in solvent-free systems: optimization of the reaction parameters, purification and characterization of the products, and biocatalyst reuse

Optimization and kinetic studies for biodiesel production from dairy waste scum oil via microwave assisted transesterification

Kinetic Parameters Investigation for The Esterification of Free Fatty Acid from Coconut Oil Mill Waste using Montmorillonite-Sulfonated Carbon from Glucose Composite Catalyst

Biocatalytic Synthesis of Flavor Ester “Pentyl Valerate” Using Candida rugosa Lipase Immobilized in Microemulsion Based Organogels: Effect of Parameters and Reusability

Application of Phosphonium- and Choline Chloride Based Deep Eutectic Solvents as Catalyst for Emulsifier Production from Low Quality Oil Assisted by Microwave Irradiation