Abstract:Highlights • The effect of vibration on the particle system is entirely determined by the gas velocity • Particle system mixing requires high vibration energy, whereas particle system separation requires low vibration energy. • 1-0.5 mm fine-grained coal blends seamlessly with magnetite powder, while -0.5 mm fine-grained coal does not mix well. • The smaller the particles, the greater their susceptibility to different air currents and vibrations. Vibro-fluidized dry coal beneficiation involves the unavoidable mixing of -1 mm coal dust into a fluidized bed, which compromises the stability and homogeneity of the bed density and reduces the effectiveness of fine-grained coal separation. To understand the features of coal powder separation and mixing (-1 mm) in a vibrating fluidized bed, as well as to achieve a uniform and stable bed density, a wide-grained dense medium consisting of -1 mm coal dust and 0.3-0.15 mm magnetite powder was homogeneously mixed in this work. The degree of density separation in the entire bed and the local mixing properties of the wide-grained dense medium were examined. It was discovered that when low vibrational energy was introduced at the same air velocity, particle separation was enhanced compared to the usual fluidized bed. Small bubbles were found to ensnare fine coal dust and migrate upwards, increasing the density separation. The introduction of high vibrational energy led to particle disorder within the bed and an increase in the level of particle mixing. The beneficial effects of the vibration on the bed diminished when the air velocity was gradually increased under the specified vibration conditions. This caused large bubbles to develop more frequently, which increased particle mixing. The 1-0.5 mm fine-grained coal exhibited the best mixing state; it was less affected by variations in air velocity and vibration levels, whereas the -0.5 mm coal dust was more affected by each variable. Furthermore, the particle system achieved a wide range of air velocity regulations without a significant segregation state change under the vibration conditions of f = 25 Hz and A=1 mm and f = 25 Hz and A=2 mm. Graphical abstract Download : Download high-res image (228KB) Download : Download full-size image

Prediction of separation density of pulsed fluidized bed based on bidisperse particle characteristics

Experimental and numerical investigation of solid behavior in a gas–solid turbulent fluidized bed

CFD Simulation and Experiments of Dynamic Parameters in Gas–solid Fluidized Bed

Distribution and Movement of Fine Particles Injected in a Gas–solid Fluidized Bed with Hydrocarbon Liquid Spray

Numerical studies of the influence of particles' size distribution characteristics on the gravity separation performance of Liquid-solid Fluidized Bed Separator

Cfd-Dem Investigation of Particle Elutriation with Electrostatic Effects in Gas-Solid Fluidized Beds

Study on the Separation and Mixing Laws of Wide-grained Dense Medium in Vibration Separation Fluidized Bed

Online Measurement of Particle Charge Density in A Gas-Solid Bubbling Fluidized Bed Through Electrostatic and Pressure Sensing

Effect of bed density on the segregation behavior of fine coal particles (<6 mm) in a gas–solid separation fluidized bed

Study on density distribution characteristics and fine coal separation of magnetically fluidized beds of microfine particles

Study on fluidization characteristics and drying characteristics of fine coal in thermal vibration separation fluidized bed

Coarse-grained CFD-DEM simulation to determine the multiscale characteristics of the air dense medium fluidized bed

Effect of fluidized bed shapes on gas-solid fluidization characters and flow regime transition

Simulation Study of Particulate Fluidization Characteristics of Fine Coals in Hindered Fluidized Bed

Dry coal beneficiation technique in the gas–solid fluidized bed: a review

Prediction of minimum fluidization velocity in pulsed gas–solid fluidized bed

Spatial distribution of bed density in a Gas-solid Fluidized Bed Coal Beneficiator (GFBCB) using Geldart A − particles

Study on a Semi-Resolved CFD-DEM Method for Rod-Like Particles in a Gas-Solid Fluidized Bed

Bubble Dynamics and Particle Orientation in a Binary Fluidized Bed Containing Spherocylinders and Spheres

Apparent viscosity of binary particle system in gas-solid separation fluidized bed

A Numerical Investigation on Segregation in Gas-Fluidized Beds of Short, Flexible Fibers