Abstract:Highlights • The effect of vibration on the particle system is entirely determined by the gas velocity • Particle system mixing requires high vibration energy, whereas particle system separation requires low vibration energy. • 1-0.5 mm fine-grained coal blends seamlessly with magnetite powder, while -0.5 mm fine-grained coal does not mix well. • The smaller the particles, the greater their susceptibility to different air currents and vibrations. Vibro-fluidized dry coal beneficiation involves the unavoidable mixing of -1 mm coal dust into a fluidized bed, which compromises the stability and homogeneity of the bed density and reduces the effectiveness of fine-grained coal separation. To understand the features of coal powder separation and mixing (-1 mm) in a vibrating fluidized bed, as well as to achieve a uniform and stable bed density, a wide-grained dense medium consisting of -1 mm coal dust and 0.3-0.15 mm magnetite powder was homogeneously mixed in this work. The degree of density separation in the entire bed and the local mixing properties of the wide-grained dense medium were examined. It was discovered that when low vibrational energy was introduced at the same air velocity, particle separation was enhanced compared to the usual fluidized bed. Small bubbles were found to ensnare fine coal dust and migrate upwards, increasing the density separation. The introduction of high vibrational energy led to particle disorder within the bed and an increase in the level of particle mixing. The beneficial effects of the vibration on the bed diminished when the air velocity was gradually increased under the specified vibration conditions. This caused large bubbles to develop more frequently, which increased particle mixing. The 1-0.5 mm fine-grained coal exhibited the best mixing state; it was less affected by variations in air velocity and vibration levels, whereas the -0.5 mm coal dust was more affected by each variable. Furthermore, the particle system achieved a wide range of air velocity regulations without a significant segregation state change under the vibration conditions of f = 25 Hz and A=1 mm and f = 25 Hz and A=2 mm. Graphical abstract Download : Download high-res image (228KB) Download : Download full-size image

Apparent viscosity of binary particle system in gas-solid separation fluidized bed

Experimental and numerical investigation of solid behavior in a gas–solid turbulent fluidized bed

Modeling Agglomeration Behavior in High Temperature Gas–Solid Fluidized Beds Via Monte Carlo Method

Research on Separation Mechanism of Liquid-Solid Fluidized Bed Separator

Simplification and application of particles kinetic equation for liquid-solid fluidized bed separator

A Volatile Spray Zone Model and Experimentation in a Gas-Solid Fluidized Bed with Liquid Injection

Experimental Investigation of Electrostatic Effect on Particle Motions in Gas-Solid Fluidized Beds

Experimental Investigation of Bubble and Particle Motion Behaviors in A Gas-Solid Fluidized Bed with Side Wall Liquid Spray

Numerical studies of the influence of particles' size distribution characteristics on the gravity separation performance of Liquid-solid Fluidized Bed Separator

Particle Fluidization Characteristics and Transition in a Hot Gas-Solid Fluidized Bed with Liquid Injection

Effect of bed density on the segregation behavior of fine coal particles (<6 mm) in a gas–solid separation fluidized bed

Study on density distribution characteristics and fine coal separation of magnetically fluidized beds of microfine particles

Study on the Separation and Mixing Laws of Wide-grained Dense Medium in Vibration Separation Fluidized Bed

Prediction of separation density of pulsed fluidized bed based on bidisperse particle characteristics

A Numerical Investigation on Segregation in Gas-Fluidized Beds of Short, Flexible Fibers

Numerical Study of Particle Injection into a Gas-Solid Fluidized Bed

Spatial distribution of bed density in a Gas-solid Fluidized Bed Coal Beneficiator (GFBCB) using Geldart A − particles

Separation performance of 0.5–1 mm fine coal in a gas–solid fluidized bed without dense medium

Bubble Dynamics and Particle Orientation in a Binary Fluidized Bed Containing Spherocylinders and Spheres

Particle-Scale Simulation of Solid Mixing Characteristics of Binary Particles in a Bubbling Fluidized Bed

Effect of fluidized bed shapes on gas-solid fluidization characters and flow regime transition