Abstract:TBM tunnelling is less used in the subway construction in prosperous city due to the limitation of the engineering geological conditions. The studies on the influence of the TBM construction on the existing buildings are also limited. Therefore, based on the engineering case of tunnel crossing existing building in the section of Haiboqiao ~ Xiaocunzhuang station of Qingdao Metro Line 1, the numerical model that simulates the construction process of TBM tunnelling in slightly weathered granite layer is established by three-dimensional finite difference software FLAC3D to analyze the influence of TBM tunnelling. The comparisons between ground deformations obtained by FLAC3D and field monitoring data in different construction stages of double-line tunnel have been made firstly to validate the numerical model. Then the ground settlement characteristics, differential settlement and the stress distribution of the existing building and the stress of segment structure have been analyzed. During TBM tunnelling under existing building, the settlement of the building as a whole tends to increase, with the maximum measured settlement of 5.45 mm and the maximum differential settlement of 1.58 mm, which meets the control standard of relevant codes. Ground settlement groove along the transverse and vertical sections occurs near the building and tunnels, and the settlement becomes smaller with the farther the distance from the building and tunnels. The settlement curve on the cross section changes dynamically and is approximately V-shaped, and its width is about 5 ~ 6 times diameter of the tunnel. For the same cross section, the range of the settlement groove after tunnelling right line increases obviously compared with that after tunnelling left line (first construction), the settlement values also increase, and the symmetrical axis of the settlement curve is shifted to the right. For the segment structure, the maximum principal tensile stress occurs inside the arch bottom of the tunnel, while the maximum principal compressive stress occurs near the arch top and arch waist, with obvious stress concentration. For the existing building, the maximum principle tensile stress occurs at the door opening of the wall on the first floor and the maximum principal compressive stress is at the corner of wall. They are less than the tensile strength and compressive strength of the segment structure and building respectively, and have enough safety margins. This paper can provide important practical reference for the deformation control and protection design of surrounding buildings for relative construction.

Tunnelling impacts and mitigation on existing structures for Bangkok MRT Orange Line

Effect of nearby undercrossing tunneling on the deformation of existing metro tunnel and construction control

Simplified analytical method for evaluating the effects of adjacent excavation on shield tunnel considering the shearing effect

Effects of Twin Tunneling Underneath on Existing Shield Tunnels

Application Of Stable Equilibrium Theory To Metro Tunnels And River-Crossing Tunnels Using Shield Tunneling Method

Deformation analysis of existing tunnel using finite element method during construction of a full-length excavation pit

Challenges in Construction of Secant Bored Piles in Sandy Soil and Within a Railway Protection Zone

Study on the Influence of an Under-Crossing Parallel Double-Line Shield Tunnel on the Existing Tunnel Structure

An in-tunnel grouting protection method for excavating twin tunnels beneath an existing tunnel

Measurement And Analysis Of The Effect Of Shield Tunnelling Of Hangzhou Subway On The Adjacent Building

Structural Monitoring of Metro Infrastructure During Shield Tunneling Construction.

Effect of foundation pit excavation and structural construction of new engineering on existing underlying tunnel

Structural Behaviors of Large-Section Mine Tunnels Undercrossing Existing Metro Lines

Analysis of Ground Settlement Caused by Double-line TBM Tunnelling Under Existing Building

Effect of metro rail extension on flood risks of Bangkok Metropolitan Authority outskirt due to climate and land use land cover changes

Design of Protection Measures for Deep Excavation of A New Underground Station Closely Adjacent to Viaduct of MRT System in Operation

A REVIEW OF THE RESEARCH ON THE IMPACT OF GROUND LOAD ON ADJACENT EXISTING SHIELD TUNNEL

Twin tunnelling caused distortions and its effect on a hospital building on mixed ground conditions

Long-Term Monitoring and Safety Evaluation of A Metro Station During Deep Excavation

Investigation of Metro Tunnel Response to Multiple Adjacent Large Excavations in Soft Soils

Study on Effect of Double-line Parallel Shield Tunneling Side-crossing on Adjacent Frame Structures