Abstract:The desulfurization efficiency of a spray tower that uses Wet Flue Gas Desulfurization (WFGD) technology can be improved by adding deflectors. This paper experimentally and numerically investigates the performance of a Deflector Spray Tower (DST) and then compares the results with an Open Spray Tower (OST) and Tray Spray Tower (TST). An experimental facility (i.e., 1:15 scale pilot plant) is established based on the WFGD system of an actual 600MW coal-fired power plant. The experiment simulates gas and liquid hydrodynamics inside the spray tower. The continuous phase is described in an Eulerian framework and liquid droplet motion is computed by the Lagrange approach. Sulfur dioxide absorption is modeled on the two-film theory, appropriate empirical correlations and semi-empirical correlations. The effect of the tray on the flow field is considered under porous media conditions. A comparison of experimental and numerical results validates the numerical simulations, showing that the Euler-Lagrange approach accurately predicts the flue flow field and liquid droplet distribution. Here, results show that deflectors positively affect flow field structure in the spray tower. The deflectors rearrange the single-phase flow field of the gas and partially solve the bias flow due to the single inlet. Therefore, peak velocity in the tower decreases such that the pressure drop for DST is 14.1% lower than the pressure drop for OST. In addition, compared with TST, DST is superior in tower resistance, with a decrease of approximately 39.7%. The SO2 desulfurization absorption model is verified in an actual 660MW power plant. Here, desulfurization efficiency is 89.6% for OST, 92.5% for TST and 96.7% for DST at the design parameter.

Study on Gas–Solid Two–Phase Flow Characteristics of One–Furnace with Two–Tower Semi–Dry Desulfurization in Circulating Fluidized Bed Boiler

Multi-scale Characteristics and Gas-Solid Interaction among Multiple Beds in a Dual Circulating Fluidized Bed Reactor System

Experimental Study of Semi-dry Flue Gas Desulfurization in Circulating Suspension Fluidized Bed

CFD-DEM simulations of a gas-solid-liquid fluidization system: Effects on the flow field and particle behavior of semi-dry desulfurization fluidized bed

Experimental Research on the Gas-Solid Flow Characteristics in Large-Scale Dual Fluidized Bed Reactor

Study on the Efficiency of Fine Particle Removal in a Single-Tower Dual-Cycle Desulfurization Process Utilizing Heterogeneous Condensation

Structure Optimization Research Based on Numerical Simulation of Flow Field in Ammonia-Based Wet Sintering Flue Gas Desulfurization

Promoting fine particle removal in double-tower cascade wet flue gas desulfurization system by flue gas temperature reduction

Simulation of Heat and Mass Transfer in Pulverized Coal Boiler Based on Gaseous Combustion Through Phase Separation Technique

Numerical study on flue gas–liquid flow with side-entering mixing

Experimental Study of Wet Flue Gas Desulphurization of Impinge Liquid Column Tower

Optimization the operation parameters of SDA desulfurization tower by flow coupling chemical reaction model

Modeling on circulating fluidized bed flue gas desulfurization

Experimental and Numerical Study on Effects of Deflectors on Flow Field Distribution and Desulfurization Efficiency in Spray Towers

Enhancement of Mass Transfer Between Flue Gas and Slurry in the Wet Flue Gas Desulfurization Spray Tower

STUDY ON TWO-STAGE DESULFURIZATION TECHNOLOGY WITH PREMIXED AND INJECTED SORBENTS IN COAL-FIRED BOILERS

Effect of operating parameters and reactor structure on moderate temperature dry desulfurization.

The In-Situ Desulphurization with Multi-Particle-Size and Multi-Flow-State for Circulating Fluidized Bed Boilers

Effect of Solids Concentration Distribution on the Flue Gas Desulfurization Process

Experiment of Optimizing Gas-Particle Flow Regime in the Square-section Circulating Suspension Bed

Experimental study of two-phase flow inside finned-tubes separator using 3-D-PDA