Abstract:Based on the actual coal chemical system, the research on the coupling technology of coal gasification chemical industry, solid oxide fuel cell and gas turbine is a new idea to accelerate the engineering and commercial development of IGFC. The Inner Mongolia Rongxin Chemical multi-nozzle opposed coal water slurry gasification and methanol production system of Shandong Energy Group Co., Ltd. was designed to carry out the construction of coal gasification chemical engineering, solid oxide fuel cell, and turbine process flows by Aspen Plus, a chemical process analysis software. The effects of operating parameters on the integrated coal gasification fuel cell power generation and methanol co-generation（IGFC-PMC） system were studied by simulation calculation, and the chemical output, power and thermal output of the system under typical conditions were analyzed. On this basis, the influences of key parameters of gasifier on output, efficiency and other operating parameters of key components were analyzed. The results show that the methanol production unit combined with fuel cells can improve the overall efficiency of the system from 57.71% to 59.22%, indicating that the new system has advantages in energy utilization efficiency. When the concentration of coal water slurry increases from 55% to 60%, there is the greatest influence on the power and efficiency of fuel cells and little improvement on the overall efficiency. The efficiency of fuel cell increases from 42.46% to 68.42%, the power increases from 2.65 MW to 4.22 MW, and the power of turbine 1st increases from 6.23 MW to 6.56 MW. When the proportion of pumping gas increases from 0 to 51.59%, the impact on methanol production is small because the pumping volume is less than 2% relative to the total amount of syngas. In addition, the overall efficiency increases from 59.20% to 60.70%. It is feasible to adjust the supply of "chemicals, heat and electricity" by extracting part of the purified gas. It is suggested to expand the generator set by setting parallel standby units, so as to reduce the difficulty of operation regulation and maintain the high efficiency of fuel cells. The optimized design of the original methanol production system not only improves the overall energy efficiency of the system, but also realizes the transformation from a single output chemical and waste heat to the combined supply of chemical, heat and electricity, providing a new idea for chemical system to relieve the pressure of production electricity and product diversity and economic optimization.

Assessment of CO2 enrichment mechanism in integrated coal gasification fuel cell combined cycle system with carbon capture

Coal Gasification Based Solid Oxide Fuel Cell Power Generation with CO2 Capture

Development of catalytic combustion and CO2 capture and conversion technology

Key CO2 capture technology of pure oxygen exhaust gas combustion for syngas-fueled high-temperature fuel cells

Study on Pure Oxygen Exhaust Gas Combustion: Key Technology of CO2 Capture for High Temperature Fuel Cell With Coal Syngas

Thermodynamic investigation of an integrated near-zero CO2 emission power generation system with SOFC, MGT, SCO2BC, and CO2 capture

Optimization of Parameters and Thermodynamics of Gasification Process for Enhanced CO2 Capture in an IGCC System

Design and optimization of a solid oxide fuel cell-inverted gas turbine integrated system with zero carbon emission for distributed cogeneration

Concept Design, Parameter Analysis, and Thermodynamic Evaluation of a Novel Integrated Gasification Chemical-Looping Combustion Combined Cycle Power Generation System

Energy, exergy and economic(3E) analyses of a CO 2 near-zero-emission power generation system with integrated supercritical water gasification of coal and SOFC

Efficiency Analysis of Warm Gas Clean up in Integrated Gasification Fuel Cell (IGFC) System

Thermodynamic and Economic Analysis of Oxy-Fuel-Integrated Coal Partial Gasification Combined Cycle

System Simulation and Parametric Analysis of Low-Concentration Coal Mine Gas Fed SOFC-CHP with Deoxygenation and Enrichment Pretreatment

Optimization of solid oxide fuel cell system integrated with biomass gasification, solar-assisted carbon capture and methane production

Enhanced coal gasification heated by unmixed combustion integrated with an hybrid system of SOFC/GT

Comparative Study of Solid Oxide Fuel Cell Combined Heat and Power System with Multi-Stage Exhaust Chemical Energy Recycling: Modeling, Experiment and Optimization

A conceptual design of catalytic gasification fuel cell hybrid power plant with oxygen transfer membrane

Performance of Planar Electrode Supported Solid Oxide Fuel Cell With Syngas as Fuel

Design and operation characteristics study of integrated coal gasification fuel cell power generation and methanol cogeneration system

Design, energy efficiency, and CO 2 emissions analysis of a power generation process of coking dry gas reforming coupled with solid oxide fuel cell and organic Rankine cycle

Study on CO2 capture upgrading of existing coal fired power plants with gas steam mixture cycle and supercritical water coal gasification