Abstract:Monoethanolamine (MEA) based CO2 capture in coal-fired power plants would consume a huge amount of the steam bleed from the steam turbines for the solvent regeneration. The unmatched steam bleed parameters for the solvent regeneration, as well as the huge amount of the process waste heat within the CO2 capture process, inevitably bringing about a significant efficiency penalty. In this study, a novel de-carbonization supercritical coal-fired power plant, which encompasses a supplementary steam turbine (SST), process heat recovery and a modified boiler heating exchangers configuration was proposed. In the proposed system, the steam bleeds for the reboiler and part of the regenerative heaters are coming from the SST, which is located in the upstream of the reheater (steam side), instead of the high and intermediate-pressure turbines (IPT), making the parameters of the steam bleed more matched with the solvent regeneration and feed water heating. In addition, part of the process heat within the CO2 capture/compression unit was efficiently recovered and beneficially used to heat the ambient air before its entering the air pre-heater. The saved flue gas can then be used to heat the feed/condensed water in the low-temperature economizer (LTE), saving part of the steam bleed from the turbines. The configuration of the superheaters/reheaters, as well as the air preheaters were also modified. The mass and energy balance as well as the system thermodynamic performance were determined by the developed models and process simulation. The economic performance of the proposed system was assessed by the cost of electricity (COE) and the cost of CO2 avoided (COA). Finally, the off-design performance of the proposed system was determined. Results showed that the energy efficiency penalty of the proposed system could decrease by 3.86%-points as compared to the reference system. The COE and COA of the proposed system without considering the CO2 transportation and storage cost were $86.11/MWh and $36.92/ton CO2, respectively, both less than those of the reference plant. The off-design operation analysis indicated that the proposed plant also featured a thermodynamics superiority in a wide range of power load variation.

Study on CO2 capture upgrading of existing coal fired power plants with gas steam mixture cycle and supercritical water coal gasification

Thermodynamic Analysis of Coal-Fired Thermal Power Units Coupled S-CO2 Energy Storage System

Optimization study on improving energy efficiency of power cycle system of staged coal gasification coupled with supercritical carbon dioxide

Proposal and investigation of a high-efficiency coal-fired power generation system enabled by chemical recuperative supercritical water coal gasification

Assessment of CO2 enrichment mechanism in integrated coal gasification fuel cell combined cycle system with carbon capture

Coal Gasification Based Solid Oxide Fuel Cell Power Generation with CO2 Capture

Collaborative Optimization for a Multi-Energy System Considering Carbon Capture System and Power to Gas Technology

Influences Of Co2 Capture On Coal Water Slurry Igcc Performance

Boiling coal in water: Hydrogen production and power generation system with zero net CO2 emission based on coal and supercritical water gasification

Performance assessment and system optimization on supercritical CO 2 double-path recompression coal-fired combined heat and power plants with MEA-based post-combustion CO 2 capture

Thermodynamic and Economic Analysis of Oxy-Fuel-Integrated Coal Partial Gasification Combined Cycle

Performance Analysis of Biomass Gasification Coupled with Ultra-Supercritical Power Generation System

An integrated de-carbonization supercritical coal-fired power plant incorporating a supplementary steam turbine, process heat recovery and a modified boiler structure

The roadmap towards the efficiency limit for supercritical carbon dioxide coal fired power plant

Study on heat integration of supercritical coal-fired power plant with post-combustion CO2 capture process through process simulation

Upgrading the Integration of Supercritical Coal-Fired Power Plant with Post-Combustion CO<SUB Align="right">2 Capture Process Through Process Simulation

Utilizing flue gas low-grade waste heat and furnace excess heat to produce syngas and sulfuric acid recovery in coal-fired power plant

Optimization study of CO 2 capture unit for subcritical coal-fired power generation unit based on Ebsilon and Aspen plus

Heat Pump Assisted Sorption Carbon Capture with Steam Condenser Heat Recovery in a Decarbonised Coal-Fired Power Plant

Energy, exergy and economic(3E) analyses of a CO 2 near-zero-emission power generation system with integrated supercritical water gasification of coal and SOFC

Process and Integration Optimization of Post-Combustion CO2 Capture System in a Coal Power Plant