Abstract:Monoethanolamine (MEA) based CO2 capture in coal-fired power plants would consume a huge amount of the steam bleed from the steam turbines for the solvent regeneration. The unmatched steam bleed parameters for the solvent regeneration, as well as the huge amount of the process waste heat within the CO2 capture process, inevitably bringing about a significant efficiency penalty. In this study, a novel de-carbonization supercritical coal-fired power plant, which encompasses a supplementary steam turbine (SST), process heat recovery and a modified boiler heating exchangers configuration was proposed. In the proposed system, the steam bleeds for the reboiler and part of the regenerative heaters are coming from the SST, which is located in the upstream of the reheater (steam side), instead of the high and intermediate-pressure turbines (IPT), making the parameters of the steam bleed more matched with the solvent regeneration and feed water heating. In addition, part of the process heat within the CO2 capture/compression unit was efficiently recovered and beneficially used to heat the ambient air before its entering the air pre-heater. The saved flue gas can then be used to heat the feed/condensed water in the low-temperature economizer (LTE), saving part of the steam bleed from the turbines. The configuration of the superheaters/reheaters, as well as the air preheaters were also modified. The mass and energy balance as well as the system thermodynamic performance were determined by the developed models and process simulation. The economic performance of the proposed system was assessed by the cost of electricity (COE) and the cost of CO2 avoided (COA). Finally, the off-design performance of the proposed system was determined. Results showed that the energy efficiency penalty of the proposed system could decrease by 3.86%-points as compared to the reference system. The COE and COA of the proposed system without considering the CO2 transportation and storage cost were $86.11/MWh and $36.92/ton CO2, respectively, both less than those of the reference plant. The off-design operation analysis indicated that the proposed plant also featured a thermodynamics superiority in a wide range of power load variation.

Simulation and comprehensive technical, economic, and environmental assessments of carbon dioxide capture for methanol production through flue gas of a combined cycle power plant

Methanol production from natural gas reforming and CO2 capturing process, simulation, design, and technical-economic analysis

Utilizing carbon dioxide from refinery for methanol and electricity co-production: System design and economic assessment

A novel structure of natural gas, electricity, and methanol production using a combined reforming cycle: Integration of biogas upgrading, liquefied natural gas re-gasification, power plant, and methanol synthesis unit

Environmental and energetic analysis of coupling a biogas combined cycle power plant with carbon capture, organic Rankine cycles and CO2 utilization processes

An integrated de-carbonization supercritical coal-fired power plant incorporating a supplementary steam turbine, process heat recovery and a modified boiler structure

Towards a sustainable, and economic production future: Proposing a new process for methanol production based on renewable hydrogen

Conceptual Design and Techno-economic Analysis of a Coal to Methanol and Ethylene Glycol Cogeneration Process with Low Carbon Emission and High Efficiency

Assessment of methanol and electricity co-production plants based on coke oven gas and blast furnace gas utilization

Comparative investigation of CO2-to-methanol process using different CO2 capture technologies

An efficient methanol pre-reforming gas turbine combined cycle with integration of mid-temperature energy upgradation and CO 2 recovery: Thermodynamic and economic analysis

Combination of CO 2 electrochemical reduction and biomass gasification for producing methanol: A techno-economic assessment

Techno-economic feasibility and comparison of coal water slurry concentration on a coal to methanol plant with consideration of carbon capture and storage

Multi-variable optimization of a geothermal power plant integrated with water electrolyzer and methanol production

Investigation of renewable methanol production from CO 2 hydrogeneration based on spectral splitting and heat integration

Techno-Economic Analysis of Integrating a CO2 Hydrogenation-to-Methanol Unit with a Coal-to-Methanol Process for CO2 Reduction

A novel system integrating water electrolysis and supercritical CO 2 cycle for biomass to methanol

Co2 Mitigation in Coal Gasification Cogeneration Systems with Integration of the Shift Reaction, Co2 Absorption and Methanol Production

Carbon-negative co-production of methanol and activated carbon from bagasse pyrolysis, physical activation, chemical looping, and methanol synthesis

Integration and optimization of methanol-reforming proton exchange membrane fuel cell system for distributed generation with combined cooling, heating and power

A System for the Combined Carbon Capture and Utilization to Produce Renewable Methanol from Biogas