Abstract:The oxy-fuel combustion contributes to carbon capture, while the recirculation of flue gas brings about high concentrations of SO2 and H2O, which can affect the transformation of minerals in high-alkali coal. The staged oxy-fuel combustion, as an effective method for NOx reduction, can also change the ash deposition behavior of high-alkali coal. Two kinds of diluting agents, including pure CO2 for O2/CO2 combustion and simulated "recycled flue gas" (CO2, SO2, and H2O) for O2/RFG combustion, were employed in the present work. The ash deposition and NO emission of high-alkali coal during the staged oxy-fuel combustion were simultaneously studied under O2/CO2 and O2/RFG conditions. The conversion ratios of fuel-nitrogen to NO (CNO) and ash deposition efficiencies (Ed) at different stoichiometric ratios in primary combustion zone (SR1) and different oxygen concentrations were obtained. Afterwards, a series of tests were performed to further analyze the ash deposits. The experimental results show that as SR1 increases from 0.6 to 1.2, CNO jumps from 2.0 % to 23.5 % (O2/CO2 combustion) and from 1.9 % to 19.9 % (O2/RFG combustion). The additions of SO2 and H2O can reduce the NO emission. With the rising SR1, Ed under the O2/CO2 and O2/RFG conditions decreases from 4.0 % to 2.6 % and from 4.8 % to 2.1 %, respectively. At high SR1, the CaSO4 amount declines and the iron contributes less to the ash deposition. In O2/RFG combustion, the small sticky particles of sodium aluminosilicates on large particle surfaces reduce, and the large particles of calcium aluminosilicates shrink because some calcium produces CaSO4. Moreover, the exposure of ferrous iron to H2O helps its oxidization so iron is harder to cause severe adhesion. As O2 concentration rises from 21 % to 40 %, CNO shows an upward trend. Meanwhile, Ed under the O2/CO2 and O2/RFG conditions increases from 2.6 % to 3.7% and from 2.3 % to 2.7%, respectively. The present work is expected to provide some conducive information for the clean utilization of high-alkali coal and secure operation of boiler, as well as large-scale CO2 capture.

Coal-Scenedesmus Microalgae Co-Firing in a Fixed Bed Combustion Reactor: A Study on CO2, SO2 and NOx Emissions and Ash

Combustion characteristics and air pollutant formation during oxy-fuel co-combustion of microalgae and lignite

Experimental Study on the Ash Deposition and NO Emission of High-Alkali Coal under the Staged O2/CO2 and O2/RFG Conditions

Synergistic effects during the co-pyrolysis and co-gasification of high volatile bituminous coal with microalgae

Co-Pyrolysis of Coal and Algae

CO2 Biofixation by the Cyanobacterium Spirulina sp. LEB 18 and the Green Alga Chlorella fusca LEB 111 Grown Using Gas Effluents and Solid Residues of Thermoelectric Origin

Mass transfer characteristics and effect of flue gas used in microalgae culture

Optimizing engine performance and reducing emissions of greenhouse gases through spirulina microalgae and nano-additive blends

Progress in the Study of Removal from Coal Fired Flue Gas by Microalgae

Experimental Investigation of NOx Emission and Ash-Related Issues in Ammonia/coal/biomass Co-Combustion in a 25-Kw Down-Fired Furnace

CO2 , NOx and SOx removal from flue gas via microalgae cultivation: A critical review.

Fluidised bed combustion and ash fusibility behaviour of coal and spent coffee grounds blends: CO and NOx emissions, combustion performance and agglomeration tendency

Co-combustion Characteristics and CO2 Emissions of Low-Calorific Multi-Fuels by TG-FTIR Analysis

Co-pyrolysis of South African bituminous coal and Scenedesmus microalgae: Kinetics and synergistic effects study

PM emissions - assessment of combustion energy transfer with Schizochytrium sp. algal biodiesel and blends in IC engine

Co-combustion of sewage sludge and Zhundong coal: Effects of combustion conditions on gaseous pollutant emission and ash properties

Experimental and Numerical Investigation of the Combustion Characteristics and NO Emission Behaviour During the Co-Combustion of Biomass and Coal

NOx Emission Characteristics of Coal and Biomass Co-firing in O2/CO2 Atmosphere

Utilization of simulated flue gas for cultivation of Scenedesmus dimorphus

K2CO3-catalytic Supercritical Water Gasification of Coal with NaAlO2 Addition to Inhibit Ash Agglomeration and Decrease the Volatility of Alkali Metals

Effect of gaseous agents on co-combustion characteristics of sewage sludge and coal